Escolar Documentos
Profissional Documentos
Cultura Documentos
Using IP passthrough
9235943
Issue 1 EN
Nokia_9300_9500_Using_IP_passthrough_en_1.fm Page 2 Tuesday, February 1, 2005 1:43 PM
Legal Notice Under no circumstances shall Nokia be responsible for any loss of data or income or
Copyright © Nokia 2005. All rights reserved. any special, incidental, consequential or indirect damages howsoever caused.
Reproduction, transfer, distribution or storage of part or all of the contents in this The contents of this document are provided "as is". Except as required by applicable
document in any form without the prior written permission of Nokia is prohibited. law, no warranties of any kind, either express or implied, including, but not limited
Nokia and Nokia Connecting People are registered trademarks of Nokia Corporation. to, the implied warranties of merchantability and fitness for a particular purpose, are
Other product and company names mentioned herein may be trademarks or trade made in relation to the accuracy, reliability or contents of this document. Nokia
names of their respective owners. reserves the right to revise this document or withdraw it at any time without prior
notice.
Nokia operates a policy of continuous development. Nokia reserves the right to make
changes and improvements to any of the products described in this document
without prior notice. Copyright to the Windows screenshots belongs to Microsoft.
Contents
Contents
Introduction............................................... 4
Installing Nokia Network Bridge ............. 5
Enabling IP passthrough........................... 7
Connecting your device to the computer8
Creating a bridge .................................... 12
Creating an Internet access point ......... 13
Troubleshooting....................................... 15
General ...................................................................................15
Installation ............................................................................15
Connections ..........................................................................16
Introduction
Introduction
IP passthrough allows you to use your Nokia 9300 or 5 Create an Internet access point for IP passthrough.
Nokia 9500 Communicator to access the Internet or
This document contains instructions for all the steps.
corporate network through your computer. With IP
passthrough, your Nokia 9300 or Nokia 9500 Tip: For best performance, perform steps 2-4
Communicator uses an IP address to access the network. without any delay between them: connect your
device to the computer immediately after
You can use IP passthrough with any application installed
enabling IP passthrough on your device, and
on your device that uses an Internet access point. This
create the network bridge connection
offers you an alternative way of accessing networks with
immediately after connecting your device to
your device. If you only exchange data between your
the computer.
device and your computer, there is no need to use IP
passthrough; a Nokia PC Suite connection is sufficient. Note: Before you start using IP passthrough,
make sure that it is not against your company
For IP passthrough, you need the following:
policy to do so.
• Nokia Network Bridge software
• A DKU-2 data cable When you use IP passthrough to connect your Nokia 9300
• A computer with Windows 2000 or Windows XP and or Nokia 9500 Communicator to the Internet, take the
access to the Internet necessary precautions to protect your device against
viruses and other security risks.
If your computer uses wireless LAN (WLAN) to access the
network, you cannot use IP passthrough. Use a network
cable connection instead.
To start using IP passthrough, you need to proceed in the
following order:
1 Install Nokia Network Bridge.
2 Enable IP passthrough on your device.
3 Connect your device to the computer.
4 Create a network bridge on your computer.
5 Once the installation is complete, click Finish. 6 To check the installation, open Control Panel, and
Enabling IP passthrough
Enabling IP passthrough
By default, the data cable connection between your device closed, the PC Suite connection can be used again as
and your computer is used for Nokia PC Suite. To be able usual.
to use IP passthrough, you must allocate the data cable
connection for IP passthrough.
To enable IP passthrough:
1 Press Desk, and select Tools→ Control panel→
Connections→ Cable setup.
2 Change the value of the Data cable mode field to either
of the following:
3 Press Done. You are asked for confirmation.
• IP passthrough — The data cable connection is used
solely for IP passthrough. If you select this option,
you cannot use PC Suite through the data cable
connection.
• IP passthrough overrides PC Suite — The data cable
connection can be used for PC Suite and IP
passthrough. If you select this option, your PC Suite
connection is terminated if an IP passthrough is
opened when you have an active PC Suite 4 Press Save to save your changes.
connection. Once the IP passthrough connection is
After a successful installation, your device is listed on You can also see a new network connection on your
Creating a bridge
Creating a bridge
When you connect your Nokia 9300 or Nokia 9500 To create a bridge:
Communicator to your computer with a data cable that 1 On your computer, click Start→ Settings→ Control
uses IP passthrough, your computer sees your device as a Panel→ Nokia Network Bridge..
new local area network (LAN) connection. Bridging 2 Select the connection from the list, and click OK.
connects two networks together so that they act as one
network.
Before you create a bridge, make sure you do the
following:
• Install Nokia Network Bridge.
• Enable IP passthrough on your device.
• Connect your device and computer with a DKU-2 data
cable.
Tip: For best performance, create the network
bridge connection immediately after
connecting your device to the computer.
Note: Create the network bridge connection
immediately after connecting your device to
the computer. Especially with Windows XP you
have to activate the bridge without delay. If
you experience any problems creating the
bridge then disconnect the cable, connect it
again and this time create the bridge
immediately.
Troubleshooting
Troubleshooting
General If this does not work, do the following:
1 Open Windows Device Manager. (Start→
If you cannot see your device on Windows Device Manager Settings→Control Panel→ System→ Hardware→
or Network Connections, do the following: Device Manager)
• Check that your device is connected to the computer
with a DKU-2 data cable.
• Check that the used data cable mode on your device is
IP passthrough or IP passthrough overrides PC Suite.
(Tools→ Control panel→ Connections→ Cable setup) In
IP passthrough overrides PC Suite mode, your device is not
shown unless you have an active IP passthrough
connection.
Installation
If you cannot start the installation, make sure that you
have administrator rights to your computer.
If you connected your device and computer before
installing Nokia Network Bridge, do the following: 2 From the Network adapters list, select the connection
created for your Nokia 9300 or Nokia 9500
1 Cancel the installation.
Communicator, right-click your mouse, and select
2 Remove the cable from your computer.
Properties.
3 Install Nokia Network Bridge.
4 Connect the data cable to your computer.
5 Install the RNDIS driver as usual.
3 On the Driver tab, click Update driver, and follow the was installed to your computer by your company,
Troubleshooting
instructions of the wizard that opens. contact your IT department.
• Bridged connections in Windows XP — If you have
bridged connections using the Windows XP native
bridging application, remove all bridges.
• VPN and firewall software — Contact your IT
department. Do not disable any VPN or firewall
software if it is against your company policy, or unless
you have adequate protection against viruses and
other security risks.
Connections
Often connection problems are caused by other software
and programs installed on the computer or the network.
In problem situations, check the following:
• Other bridging software — Remove all other bridging
software from your computer. If the bridging software