Escolar Documentos
Profissional Documentos
Cultura Documentos
SERVICE MANUAL
This service manual shows only the differences between the model LC370SL8 and the original model LC370SS8. All other information is described in the service manual of the model LC370SS8.
LC370SL8
TABLE OF CONTENTS
Block Diagrams . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . Schematic Diagrams / CBAs and Test Points . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . Wiring Diagram . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . Different parts from the original model (LC370SS8) . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1-1 2-1 3-1 4-1
CAUTION ! Fixed voltage (or Auto voltage selectable) power supply circuit is used in this unit. If Main Fuse (F501) is blown , check to see that all components in the power supply circuit are not defective before you connect the AC plug to the AC power supply. Otherwise it may cause some components in the power supply circuit to fail.
4A/125V
CAUTION ! : For continued protection against risk of fire, replace only with same type 4 A, 125V fuse. ATTENTION : Utiliser un fusible de rechange de mme type de 4A, 125V.
NOTE: The voltage for parts in hot circuit is measured using hot GND as a common terminal.
D502 - D505
LINE FILTER
BRIDGE RECTIFIER
HOT
Q637
10
4A 125V
ACL HOT-GND
INVERTER CBA
14
Q644 Q641
Q601 SWITCHING
2 9
BLOCK DIAGRAMS
1-1
6 13 12
Q636
P-ON-H
IC637 JS632
7 11 3 +3.3V 2 REG
AL+3.3V
JS612
Q632
Q643 IC603 4 3 2 1
Q631
A71G1BLP
HOT
COLD
Q1,Q2,Q3
Notes:
1. Do not use the part number shown on these drawings for ordering. The correct part number is shown in the parts list, and may be slightly different or amended since these drawings were prepared. 2. All resistance values are indicated in ohms (K = 103, M = 106). 3. Resistor wattages are 1/4W or 1/6W unless otherwise specified. 4. All capacitance values are indicated in F (P = 10-6 F). 5. All voltages are DC voltages unless otherwise specified.
2-1
LC4N_SC
LIST OF CAUTION, NOTES, AND SYMBOLS USED IN THE SCHEMATIC DIAGRAMS ON THE FOLLOWING PAGES: 1. CAUTION:
CAUTION: FOR CONTINUED PROTECTION AGAINST RISK OF FIRE, REPLACE ONLY WITH SAME TYPE_A,_V FUSE. ATTENTION: UTILISER UN FUSIBLE DE RECHANGE DE MME TYPE DE_A,_V.
2. CAUTION:
Fixed Voltage (or Auto voltage selectable) power supply circuit is used in this unit. If Main Fuse (F501) is blown, first check to see that all components in the power supply circuit are not defective before you connect the AC plug to the AC power supply. Otherwise it may cause some components in the power supply circuit to fail.
3. Note:
1. Do not use the part number shown on the drawings for ordering. The correct part number is shown in the parts list, and may be slightly different or amended since the drawings were prepared. 2. To maintain original function and reliability of repaired units, use only original replacement parts which are listed with their part numbers in the parts list section of the service manual.
Voltage
2 Examples: 1. "1-D3" means that line number "1" goes to the line number 1 "1" of the area "D3". 2. "1-B1" means that line number "1" goes to the line number "1" of the area "B1".
AREA B1 1-D3 A B C D
2-2
LC4N_SC
VOLTAGE CHART
CN301 Pin No. 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20 21 22 23 Voltage 0 12.2 12.2 3.4 0 5.0 5.0 9.2 0 5.1 5.1 5.1 0 2.5 2.5 2.5 0 15.6 0 34.6 0 3.2 1.1
2-3
A71G1SCP1
2-4
A71G1SCD5
BA71F0F01061
2-5
COMPONENT -Y-IN1
COMPONENT -Pb-IN1
COMPONENT -Pr-IN1
COMPONENT -Y-IN2
COMPONENT -Pb-IN2
CN1150 1 2
COMPONENT -Pr-IN2
COMPONENTAUDIO(L)-IN1
CN1200 1 2
BACK LIGHT
COMPONENTAUDIO(R)-IN1
CN1250 1 2
BACK LIGHT
COMPONENTAUDIO(L)-IN2
COMPONENTAUDIO(R)-IN2
CN7501 24 23 22 21 20 19 18 17 16 15 14 13 12 11 10 9 8 7 6 5 4 3 2 1 GND +5V/+12V-LCD +5V/+12V-LCD AL+3.3V GND P-ON+5V P-ON+5V P-ON+9V GND +4V +4V +4V GND +2.5V +2.5V +2.5V GND +15V GND +35V GND PROTECT1 PROTECT2 SP802 SPEAKER L-CH CN1300 1 2 BACK LIGHT
P-ON+9V GND D+5V GND NU GND NU NU GND AUDIO(R) AUDIO(L) GND SDA1 SCL1 GND S-VIDEO-Y S-VIDEO-C GND VIDEO-Pr VIDEO-Pb GND VIDEO-Y GND VIDEO
CN3018 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20 21 22 23 24
CN3010 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20 21 22 23
CN301 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20 21 22 23
VIDEO-IN1
WIRING DIAGRAM
3-1
CN801 SP-P(R) 2 CLN801 SP-N(R) 1 SP801 SPEAKER R-CH AC501 AC CORD CN101B 1 2 3 4 5 6 7 8 GND REMOTE AL+3.3V NU NU LED2 LED1 NU CN001 1 2 3 4 IR SENSOR 5 CBA 6 7 8 CN3002 1 2 3 4 5 6 CN3025 1 2 3 4 5 D+1.0V-VDDC D+1.0V-VDDC +2.5V-UNDER +2.5V +2.5V CN1 1 2 3 DIGITAL 4 5
AUDIO(L) -IN1
HDMIAUDIO(L)-IN
CN1350 1 2
BACK LIGHT
AUDIO(R) -IN1
HDMIAUDIO(R)-IN
D+5V/+12V-LCD D+5V/+12V-LCD D+5V/+12V-LCD D+5V/+12V-LCD D+5V/+12V-LCD GND GND GND IX-TX3(+) IX-TX3(-) GND IX-CLK(+) IX-CLK(-) GND IX-TX2(+) IX-TX2(-) GND IX-TX1(+) IX-TX1(-) GND IX-TX0(+) IX-TX0(-) GND GND GND VCOM NU GND GND GND CN1400 1 2 BACK LIGHT
CN3023 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20 21 22 23 24 25 26 27 28 29 30
VIDEO-IN2
AUDIO(L) -OUT
AUDIO(L) -IN2
AUDIO(R) -OUT
AUDIO(R) -IN2
HDMICONNECTOR-1
S-VIDEO -IN1
S-VIDEO -IN2
CN3014 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20 21 22 23 PROTECT3 P-ON-H GND SCL GND SDA GND REMOTE AMP-STBY AMP-MUTE NU NU GND AUDIO(L)-OUT GND AUDIO(R)-OUT GND LED1 LED2 NU NU NU GND
CN302 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20 21 22 23
CN552 1 2 3 4 5 6 7 INVERTER 8
CBA
CN3001 1 2 3 4 5 6 7 8
JACK CBA
CN102
SUB CBA
FUNCTION CBA
6 5 4 3 2 1
A71G1WI
ELECTRICAL PARTS DIGITAL MAIN CBA UNIT MPS CBA POWER SUPPLY CBA(MPS-1) C802 C803 C806 C807 C809 C810 C842 C843 L801 L802 L803 L804 R654 1ESA14700 1ESA14701 ----------
CHIP CERAMIC CAP .(1608) B K 0.47F/16V CHD1CK30B474 CHIP CERAMIC CAP .(1608) B K 0.47F/16V CHD1CK30B474 CHIP CERAMIC CAP .(1608) B K 0.047F/50V CHD1JK30B473 CHIP CERAMIC CAP .(1608) B K 0.047F/50V CHD1JK30B473 CHIP CERAMIC CAP .(1608) B K 0.047F/50V CHD1JK30B473 CHIP CERAMIC CAP .(1608) B K 0.047F/50V CHD1JK30B473 CHIP CERAMIC CAP .(1608) B K 0.47F/16V CHD1CK30B474 CHIP CERAMIC CAP .(1608) B K 0.47F/16V CHD1CK30B474 COIL RADIAL LHLP10NB680M 68H COIL RADIAL LHLP10NB680M 68H COIL RADIAL LHLP10NB680M 68H COIL RADIAL LHLP10NB680M 68H CARBON RES. 1/4W J 4.7K JACK CBA(MPS-4) LLF6800TU003 LLF6800TU003 LLF6800TU003 LLF6800TU003 RCX4JATZ0472 ----------
Not used Not used Not used Not used Not used Not used Not used DIGITAL SUB CBA 1ESA15014 JTED005ER045
CN1 Q1 Q2 Q3 R1
PNP TRANSISTOR POWER 2SA1887(F) QQWZ2SA1887F PNP TRANSISTOR POWER 2SA1887(F) QQWZ2SA1887F PNP TRANSISTOR POWER 2SA1887(F) QQWZ2SA1887F METAL OXIDE FILM RES. 2W J 0.68 RN02R68DP004
20070718
4-1
A71G1PL
2007 Funai Electric Co., Ltd. All rights reserved. No part of this manual may be reproduced, copied, transmitted, disseminated, transcribed, downloaded or stored in any storage medium, in any form or for any purpose without the express prior written consent of Funai. Furthermore, any unauthorized commercial distribution of this manual or any revision hereto is strictly prohibited. Information in this document is subject to change without notice. Funai reserves the right to change the content herein without the obligation to notify any person or organization of such changes. with the design is a registered trademark of Funai Electric Co., Ltd and may not be used in any way without the express written consent of Funai. All other trademarks used herein remain the exclusive property of their respective owners. Nothing contained in this manual should be construed as granting, by implication or otherwise, any license or right to use any of the trademarks displayed herein. Misuse of any trademarks or any other content in this manual is strictly prohibited. Funai shall aggressively enforce its intellectual property rights to the fullest extent of the law.