Escolar Documentos
Profissional Documentos
Cultura Documentos
Connectivity
- Independent Ethernet & Serial ports - Compatible with most SCADA protocols: Ethernet/IP & Serial (MODBUS / DNP-3 / IEC etc) - Ethernet Port is 10/100Mbps (auto MDIX sensing) IEEE 802.3u - Selectable 300 - 38.4 kbps asynchronous RS-232 interface - Serial Ports supported via interface RS-232/RS-485 compatible with T-MOD 400 - Mixed network configuration allows virtual channels for Serial/Ethernet/Serial communications *
Ethernet
- Maximum utilization with narrowband channel (12.5 kHz & 25 kHz) - Smart peer-to-peer repeating - Broadcast filtering - Real time dynamic compression and decompression of data and protocol Headers - Flexible system configuration using SNMP - Advanced commissioning tools and remote diagnostics including SNMP - Networks can work as Ethernet only, Serial only or mixed Ethernet & Serial * - RS-232 serial support working in serial mode or Serial-Ethernet / Ethernet -Serial - Priority direction established Master/Remote - Collision avoidance system integrated with Farell Instruments designed Protocol - Intelligent routing adapted to radio network - Integrated Web server - Ethernet protocols: ARP, UDP, TCP, TELNET, HTTP, SNMP, reduced ICMP and ISO/TP * - Serial to Ethernet conversion with adapters - Protocol conversion: SIEMENS S5, S7; TOSHIBA; MODBUS-RTU; OMRON HOST-LINK, ETC *
Security
- Secure operation with 128-bit AES encryption - Access protection through authenticated Radius server support, CHAP, PAP and KERBEROS * - Password protected remote configuration including SNMP - Resistant to radio Ethernet surfers
* Available as option
IP-MOD
Radio
Transmitter
- Radio Frequency Range: UHF: 403-520 MHz (various sub-frequency bands available) VHF: 138-174 MHz (various sub-frequency bands available) - Independent Tx and Rx frequencies programmable within sub-frequency band - Channel Selection: Dual synthesizer, 6.25 kHz channel step - Channel Spacing: 12.5 kHz or 25 kHz - Frequency Accuracy: 1ppm (-30C to +70C) - Ageing: 1ppm/year - Operational Modes: Simplex, Half duplex or Full duplex * - Configuration: Via Windows based software - Precise measurement of Temperature and Supply Voltage - Compliances: Radio ETSI ETS EN 300 113-2 EMC ETS EN 301 489-5 Electrical security UNE EN 60950 UNE EN 60215 - Tx Power: 0.1 5 W (+37 dBm) User configurable with high VSWR protection - Tx Power: 1-10 W (+40 dBm) * - Embedded VSWR and Power Measurement with alarm signaling for High VSWR or out of range power - Modulation: 4 level FSK - Timeout Timer: Programmable 0-255 seconds - PTT Control: Automatic
Receiver
Connections
- BitErrorRate: 1x10e-6 @ -110 dBm (9600 bps@12.5 kHz) - Adjacent channel Selectivity: Better than 60 dB - Precise measurement of RSSI
General
- Antenna: N female type connector 50 Ohms - Ethernet Port: RJ45 Ethernet IEEE 802.3u 10/100 BASE-T. Cat. 6e - Data port: 1xRS-232 Female DB15 DCE.300-38.400 bps (RS-232 & RS-485 when serial mode) - Auxiliary port: 1xRS-232 Female DB25 for configuration, diagnostic and firmware updating - Power: 2 pin locking, polarized connector supplied - Led Display: Multimode Indicators for Pwr, Aux, TxD, RxD and alarms
- Power Supply:
175mm
60mm
190mm
12.6 Vdc nominal (10.8-15.6 Vdc) Isolated 24 Vdc (18 to 36 Vdc) and 48 Vdc (36 to 75 Vdc) * - Temp Range: -30C to +70C - Humidity: 95% at 40C without condensation - Transmit Current: < 1600 mA nom @ 12 Vdc 5 W - Receive Current: < 215 mA nom @ 12 Vdc - Protected against reverse polarity and over voltage by an internal resetable fuse - Housing: Rugged aluminium injection enclosure - Dimensions: 190 x 175 x 60 mm without antenna connector - Mounting: Two types DIN rail mounting, front or lateral - Weight: 1.26 kg - Protection: IP-52
* Available as option
Farell Instruments reserves the right to change any information in this brochure without notice
Farell Instruments S.L. Telematica 17 08110 Montcada i Reixac Spain Tel: +34 93 572 52 50 - Fax: +34 93 572 52 60 sales@farell-i.com www.farell-i.com
IP-MOD
Ethernet Mode
Ethernet
Serial Mode
IP MOD Serial
IP MOD Ethernet
IP MOD IP MOD
AD-ON
AD-ON
Serial
Ethernet
Ethernet
virtual channel B
IP MOD Serial
AD-ON
Serial
Farell Instruments reserves the right to change any information in this brochure without notice
Farell Instruments S.L. Telematica 17 08110 Montcada i Reixac Spain Tel: +34 93 572 52 50 - Fax: +34 93 572 52 60 sales@farell-i.com www.farell-i.com