Escolar Documentos
Profissional Documentos
Cultura Documentos
PROJECT NO-4
INDEX:
1. Introduction
2. Variables used in the line code program.
3. Program code
4. Graphics results
5. Conclusion
3
3
4
8
11
PROJECT NO-4
1. INTRODUCTION:
In this Project we will Identify the Fault by Phase selection in Matlab through
program code.
We will see also how to work with some commands from Matlab that will be
useful to obtain some graphics that will help to get some information about the
phase detection of the Fault.
VT ratio
omeg_1=100*pi;
Ts=0.001;
sampling period
fi=omeg_1*Ts/2;
hc=[1, 1]/(2*cos(fi));
Cosine component
hs=[-1, 1]/(2*sin(fi));
Sine component
h_cs=hc+hs*i;
PROJECT NO-4
3. PROGRAM CODE:
Program code.
% LABORATORY 4: PHASE SELECTION
clear all;
theta_i=1;
% CT ratio
theta_v=1;
% VT ratio
omeg_1=100*pi;
Ts=0.001;
% sampling period
fi=omeg_1*Ts/2;
% Cosine component
% Sine component
% Filter in the complex form
PROJECT NO-4
ISa_R=real(ISa);
ISa_I=imag(ISa);
ISb_R=real(ISb);
ISb_I=imag(ISb);
ISc_R=real(ISc);
ISc_I=imag(ISc);
%--------------------------------------------------------------------------
PROJECT NO-4
RATIO_20=IS2(61:120)./IS0(61:120);
PROJECT NO-4
PROJECT NO-4
4. GRAPHICS RESULTS:
Graphics result from IIIA :
Description:
This graphics shows the results from the file named as IIIA.pl4. It depicts
that in the first graphics a fault it is detected in one of the phases.
Because the red color we know that is the phase A. So that is the only
information that we can get in the first one. The next step as we had in
the theory we analyze the symmetrical components. The blue one its the
zero sequence is different than 0, moreover we know that the ground is
8
PROJECT NO-4
involved in the fault. So the last step to recognize the kind of fault so we
must analyze the alpha and beta parameters, they are 0 it means that
the fault is:
PROJECT NO-4
Description:
Following the same criteria as before we can say that this time in the fault are
involved only two phases, being C and B phases involved. From the second
graphic we get that we have 0 for the zero sequence so the ground in not
involved. The last step is to identify beta and alpha parameter so alpha is 180 so:
10
PROJECT NO-4
5.CONCLUSION:
A fault in an electric power system is studied in this project through MATLAB
programming.
Any abnormal flow of electric current in an electric power system is considered as
a fault.
In this particular project the fault is occurred between two phases B and c and
phase A to Ground also.
11