Você está na página 1de 2

FLEXOVIT USA, INC.

MATERIAL SAFETY DATA SHEET

Flammability Rating

Used to comply with OSHA's Hazard Communication Standard, 29 CFR 1910.1200 Health SECTION I - NAME AND PRODUCT
Company Name: Flexovit Abrasives Address: 1305 Eden-Evans Road

Reactivity Rating

Rating 0 0

Angola, NY 14006
Phone: 800-689-3539

Date Updated: 11/1/2011

Hazard Rating

Product: Cartridge Rolls, Spiral Band Sleeves,

Cross Pads, Square Pads SECTION II - COMPOSITION % By Ingredient Silicon Carbide Aluminum Oxide Garnet Zirconium Oxide Weight N/A N/A N/A N/A OSHA Regulate N/A N/A N/A N/A Cas # N/A N/A N/A N/A

NFPA HAZARD RATING CODE

OSHA PEL 15 mg/m 15 mg/m 15 mg/m 15 mg/m


3 3 3 3

AGGIH TLV 10 mg/m 10 mg/m 10 mg/m 10 mg/m


3 3 3 3

Other Limits N/A N/A N/A N/A

Carcinogen No No No No

SECTION III - PHYSICAL/CHEMICAL CHARACTERISTICS Boiling Point Vapor Pressure Vapor Density Solubility in Water (mm Hg.) (AIR=1) N/A N/A N/A N/A Specific Gravity Melting Point Evaporation Rate Appearance/Odor (Butyl Acetate=1) (H20=1) N/A N/A N/A

Color of paper/coated w/abrasive material

SECTION IV - FIRE AND EXPLOSION DATA Flash Point Flammable Limits Special Fire Fighting Procedures Extinguishing Media: Water, CO2, water, foam dry chemical N/A N/A N/A Lower EL Upper EL Unusual Fire or Explosion Hazards N/A N/A N/A

Flexovit Cartidge Rolls, Spiral Bands, Pads

pg 1 of 2

FLEXOVIT USA, INC.


SECTION V - REACTIVITY DATA Stability: Stable Incompability (Materials to Avoid): N/A Hazardous Decomposition or Byproducts: In use, dust and decomposing resin system fumes are generated. In most cases the material removed from the work piece will be significantly greater than the coated abrasive product components. Hazardous Polymerization: Will not occur Conditions to Avoid: N/A SECTION VI - HEALTH HAZARD DATA Routes of Entry Inhalation Dust during use Health Hazards (Acute and Chronic) Carcinogenicity N/A Signs and Symptoms of Exposure: Coughing, shortness of breath, irritation of the eyes. During use on some materials elevated sound levels may be created which effect hearing. Medical Conditions Generally Aggravated by Exposure: Emergency and First Aid Procedures: Remove to fresh air, apply artificial respiration as needed. For eyes-wash with large amounts of water. OBTAIN FIRST AID OR MEDICAL ASSISTANCE IF NEEDED. SECTION VII- STORAGE HANDLING AND USE PROCEDURES Steps to be Taken In Case Material is Released or Spilled: Normal clean up procedures Waste Disposal Method: Standard landfill methods consistent with applicable Fed., State and local laws. Precautions to be Taken in Handling and Storing: Handle with adequate ventilation. See OSHA 29CFR1910.94 (Ventilation) and OSHA 29CFR1910.1000 (Air Contaminates) Other precautions Normal use: Handle with adequate ventilation. See OSHA 29CFR1910.94 (Ventilation) and OSHA 29CFR1910.1000 (Air Contaminates), OSHA CFR1910.213 (P) Sanding Machines. SECTION VIII- CONTROL MEASURES Protection Respiratory Ventilation Protective Gloves Eye Protection Hearing Protection Hygienic Practices Requirements and Referrals As needed, approved dust respirator OSHA 24 CFR 1910-134 Local and mechanical exhaust recommended. Not required but use if desired. N/A As needed. Refer to OSHA 29 CFR 1910.215 N/A COMPANY USE The information and recommendations set forth herein are taken from sources and references believed to be accurate and complete as of the date hereof. However, Flexovit USA Inc. makes no expressed or implied warranty with respect to the accuracy of the information or the suitability of the recommendations, and assumes no liability to any user thereof. N/A NTP? N/A IARC Monographs N/A OSHA Regulated N/A Skin Not absorbed in skin Ingestion Dust Conditions to Avoid: N/A

Flexovit Cartidge Rolls, Spiral Bands, Pads

pg 2 of 2

Você também pode gostar