Escolar Documentos
Profissional Documentos
Cultura Documentos
78 - 81)
A. Is the capacity of the local loop B. Is guaranteed C. Is marked as discard eligible D. Notifies the DTE that the Frame Relay network is congested
3. What three basic components are needed when connecting sites through the WAN?
(Choose three.) A. A device to convert signals and to provide coding and line clocking B. A device to convert information into signals C. A device to convert signals into information D. A transmission circuit
4. Which three LMIs do Cisco routers support? (Choose three.)
5. What is the capacity of the local loop that is guaranteed by the ISP called?
A. Congestion Information Rate B. Control Information Rate C. Committed Information Rate D. Conformed Information Rate
A. It prevents updates received on one interface from being forwarded out other interfaces. B. It prevents updates received on one interface from being forwarded out the same interface. C. It is used with distance vector routing protocols. D. It cannot be disabled.
7. Which of the following commands creates a static Frame Relay map from R3 to R2 in the
A. frame-relay map ip 10.1.1.2 102 broadcast B. frame-relay map ip 10.1.1.1 201 broadcast C. frame-relay map ip 10.1.1.2 203 broadcast D. frame-relay map ip 10.1.1.2 302 broadcast E. frame-relay map ip 10.1.1.1 301 broadcast
A. cisco B. ansi C. broadcast D. ietf E. multicast congestion clears. A. DE B. CIR C. CBIR D. BECN
9. DTEs receiving frames with the __________ bits set try to reduce the flow of frames until
10. Which of the following are required tasks when you configure Frame Relay? (Choose
two.) A. Configure the LMI B. Configure static or dynamic address mapping C. Enable Frame Relay encapsulation on an interface D. Configure Frame Relay SVCs E. Configure Frame Relay traffic shaping
11. Which of the following are LMI extensions? (Choose all that apply.)
A. Multicasting B. Keepalives C. Local addressing D. Global addressing E. Clock synchronization F. VC status messages G. Broadcasting
12. Which command displays the number of FECNs and BECNs received by a router?
A. show interface serial 0/0/0 B. show frame-relay pvc C. show frame-relay map D. show frame-relay lmi
13. The show interfaces command displays how the encapsulation is set up, along with
Layer 1 and 2 information, including _______________. (Choose three.) A. PVC statistics B. LMI DLCI C. LMI type D. Current map entries E. Frame Relay DTE/DCE type
14. How often is the Frame Relay keepalive sent on Cisco serial interfaces?
15. Which of the following are displayed when you use the show frame-relay lmi
command? (Choose two.) A. LMI type B. DLCI number C. The number of status messages sent and received D. Current map entries
16. Which of the following helps isolate a problem between your router and the carriers
frame switch? A. Any nonzero invalid items B. Any zero invalid items C. Any nonzero valid items D. Any zero valid items
17. A PVC status could be which of the following? (Choose three.)
A. Passive B. Active C. Inactive D. Valid E. Deleted A. IETF B. Cisco C. ANSI D. ITU E. TIA F. EIA
all that apply.) A. Configure the LMI B. Configure static or dynamic address mapping C. Enable Frame Relay encapsulation on an interface D. Configure Frame Relay SVCs E. Configure Frame Relay traffic shaping