Você está na página 1de 1

When Required Battery Electrolyte Level - Check Battery, Battery Cable or Battery Disconnect Switch Replace Bearings - Adjust

Cutting Edges and End Bits - Inspect/Replace Engine Air Filter Primary Element - Clean/Replace Engine Air Filter Secondary Element - Replace Engine Air Precleaner - Clean Ether Starting Aid Cylinder - Replace Fuel System - Prime Fuses and Circuit Breakers - Replace/Reset Oil Filter - Inspect Radiator Core - Clean Radiator Pressure Cap - Clean/Replace Ripper Tip and Shank Protector - Inspect/Replace Winch Wire Rope - Install Window Washer Reservoir - Fill Windows - Clean Every 10 Service Hours or Daily Backup Alarm - Test Braking System - Test Cab Filter (Fresh Air) - Clean/Inspect/Replace Cooling System Level - Check Engine Oil Level - Check Fuel System Primary Filter/Water Separator - Drain Horn - Test Hydraulic System Oil Level - Check Indicators and Gauges - Test Pivot Shaft Oil Level - Check Seat Belt - Inspect Transmission System Oil Level - Check Walk-Around Inspection Every 50 Service Hours or Weekly Cab Filter (Recirculation) - Clean/Inspect/Replace Ripper Linkage and Cylinder Bearings - Lubricate Track Pins - Inspect Every 250 Service Hours or Monthly Air Conditioner Belt - Inspect/Adjust/Replace Alternator and Fan Belts - Inspect/Adjust/Replace Angle Blade Manual Tilt Brace - Lubricate Coolant Sample (DEAC) - Obtain Cooling System (DEAC) Additive - Add Engine Oil Sample - Obtain Engine Oil and Filter - Change Equalizer Bar End Pins Oil Level - Check Fan Drive Pulley and Idler - Lubricate Final Drive Oil Level - Check Fuel Tank Water and Sediment - Drain Track - Check/Adjust Winch Fairlead Rollers - Lubricate Winch Oil Level - Check Initial 500 Service Hours Coolant Sample - Obtain Winch Oil and Breather - Change/Clean

Every 500 Service Hours or 3 Months Engine Crankcase Breather - Clean Engine Oil and Filter - Change Fuel System Primary Filter - Replace Fuel System Secondary Filter - Replace Fuel Tank Cap Filter and Strainer - Replace/Clean Hydraulic System Oil Filters - Replace Hydraulic System Oil Sample - Obtain Recoil Spring Compartment Oil Level - Check Transmission System Oil Filter - Replace Transmission System Oil Sample - Obtain Window Wipers - Inspect/Replace Initial 1000 Service Hours Electronic Unit Injector - Inspect/Adjust Engine Valve Lash - Check/Adjust Engine Valve Rotators - Inspect Every 1000 Service Hours or 6 Months Battery - Inspect Fan (Variable) - Inspect Fan Hub Oil (Variable) - Check Lift Cylinder Yoke Bearings - Lubricate Rollover Protective Structure (ROPS) and Falling Object Protective Structure (FOPS) - Inspect Transmission Breather - Clean Transmission System Oil and Screens - Change/Clean Winch Oil and Breather - Change/Clean Every 2000 Service Hours or 1 Year Final Drive Oil - Change Hydraulic System Oil - Change Radiator Guard Pin Joint - Inspect Track Roller Frame Guides - Inspect Every Year Air Conditioner In-Line Dryer - Replace Coolant Sample - Obtain Engine Air Filter Primary Element - Replace Every 3000 Service Hours or 2 Years Cooling System (DEAC) Coolant - Change Cooling System (ELC) Extender - Add Cooling System Water Temperature Regulator Replace Fan (Variable) Oil (Mineral) - Change Every 3 Years Seat Belt - Replace Every 6000 Service Hours or 4 Years Cooling System (ELC) Coolant - Change Electronic Unit Injector - Inspect/Adjust Engine Valve Lash - Check/Adjust

Você também pode gostar