Você está na página 1de 5

2.

Evaluate each of the following to three significant figures and express each answer in SI units using an appropriate prefix: (a) (200)2 kN, (b) (0.005 mm)2, and (c) (400 m)3..

3. Determine the area of the following sheet in m2 and ft2:

Two forces P and Q are applied as shown at point A of a hook support. Knowing that P =15 N and Q =25 N, determine the magnitude and direction of their resultant.

8. Determine the magnitude of the resultant force acting on the bracket and its direction measured counterclockwise from the positive u axis.

10. The 200-N force is to be resolved into components along lines a-a and b-b. (a) Determine the angle using trigonometry knowing that the component along a-a is to be 150 N. (b) What is the corresponding value of the component along b-b?

12. Two control rods are attached at A to lever AB. Using trigonometry and knowing that the force in the left-hand rod is F1 =30 N, determine (a) the required force F2 in the right-hand rod if the resultant FR of the forces exerted by the rods on the lever is to be vertical, (b) the corresponding magnitude of FR.

14. If = 45, F1 = 5 kN, and the resultant force is 6 kN directed along the positive y axis, determine the required magnitude of F2 and its direction .

16. Determine the x and y components of each of the forces shown.

18. If = 30 and F2 = 3 kN, determine the magnitude of the resultant force acting on the plate and its direction measured clockwise from the positive x axis.

20. Three forces act on the bracket. Determine the magnitude and direction of F2 so that the resultant force is directed along the positive u axis and has a magnitude of 250N.

The spur gear is subjected to the two forces caused by contact with other gears. Express each force as a Cartesian vector, also determine the resultant of the two forces and express the result as a Cartesian vector.

24. The force F acts on the bracket within the octant shown. If the magnitudes of the x and z components of F are Fx = 300 N and Fz = 600 N respectively, and = 60, determine the magnitude of F and its y component. Also, find the coordinate direction angles and .

26. The shaft S exerts three force components on the die D. Find the magnitude and coordinate direction angles of the resultant force. Force F2 acts within the octant shown.

28. Determine the magnitude and coordinate direction angles of F2 so that the resultant of the two forces is zero.

30. Specify the magnitude of F3 and its coordinate direction angles 3, 3, 3 so that the resultant force FR = {9j} kN.

Você também pode gostar