Escolar Documentos
Profissional Documentos
Cultura Documentos
OUTLINE
Introduction Aims and Objectives
March 13
The aims and objectives of the present work are as underTo develop a single phase inverter for solar home lighting system purchased for the Department of Electrical Engineering, VNIT, Nagpur. To verify the working of the inverter by connecting CFLs as load. To observe the output voltage waveform under various load conditions. To find the efficiency of the inverter and plot the output vs efficiency curve. March 13 To find the Total Harmonic Distortion (THD) of the
Motivation
Emerging Renewable Energy Technology Keeping in view power crises in the India, everyone is keen to adopt it. Nagpur is going to be solar city in future. (MNRE) Immediate return and cost saving technology over life.(Life Cycle Cost Saving) Easy to adopt with less efforts No INVERTER is purchased for Dept.Solar PV system. March 13
March 13
sun
Charge controller
INVERTER
March 13
March 13
3.
4.
5.
Solar PV Charge Controller:-Max. charging current - 5 A -Max. Load current - 5A -Nominal voltage - 12 V -Fuse - 5A DC Fan:Volts 12 V DC,14 W Compact Florescent Lamps Volts 12 V DC,9 W, 2 No.s
March 13
controller, battery ,oscillator-cum-divider, driver, inverter transformer and power amplifier . The battery is charged through the PV module through solar charge controller. Solar charge controller prevents over charging and deep discharging of battery.
March 13
SOLAR PANEL
BATTERY
POWER SUPPLY
DRIVER CIRCUIT
POWER AMPLIFIER
INVERTER TRANSFORMER
LOAD
10
March 13
March 13
10
DESIGN OF INVERTER
11
March 13
EXPLANATION
The battery is charged through solar module and is
connected to the circuit. The terminals of the battery should be connected properly.If the reverse situation occurs,LED1 glows to indicate the wrong polarity. (Refer Figure ). If the switch S is closed, the LED3 glows to indicate power ON and 12 V d.c. reaches regulator IC 7805.The output of IC 7805 is fed to the oscillator-cum-divider. For indication of low battery level, a dual operational amplifier IC LM358 has been used. Fixed reference voltage of 5.1V is applied to the positive input, while sensing voltage is applied to its negative input.
12 March 13
CONTD.
f=100 Hz is produced at pin 3 i.e. at pin 5 of IC 7473
which produces 50 Hz square wave output at pins 8 and 9 of IC 7473. IC 7473 acts as a bistable multivibrator which only change the states when a trigger pulse is applied. If flips to one state when triggered and flops to other state when it is triggered . IC 7473 acts as a J-K flipflop.
13
March 13
A.DRIVER CIRCUIT
One of the outputs of IC 7473 is coupled to the base
of T1 through diode D1 via series limiting resistance. Another output at pin 9 is coupled to the base of T2 through diode D2 via other series limiting resistance. The transistors T1 and T2 are acting as a MOSFET drivers. When T1 conducts T2 is in cut off and vice versa.
14
March 13
MOSFETs(F1 THROUGH F3)which are connected in parallel on a heat sink. The collector of transistor T2 is connected to the MOSFETs(F4 THROUGH F6)which are connected in parallel on a heat sink. When T1 conducts corresponding MOSFETs (F1 through F3)remains cut off while voltage of collector of T2 is at 5V.Hence current flows through half of the inverter transformer primary. When T2 conducts corresponding MOSFETs (F4 through F6)remains cut off while voltage of collector of T1 is at 5V.Hence current flows through half of the inverter transformer primary.
15
March 13
C. POWER AMPLIFER
The power amplifier consists of two set of
16
March 13
RESULTS
Output at pin 3 of LM555= 5V peak to peak,f=100Hz.
Vrms=240 V,f=50 Hz
17
March 13
18
March 13
19
March 13
20
March 13
21
March 13
22
March 13
23
March 13
24
March 13
25
March 13
26
March 13
27
March 13
28
March 13
29
March 13
For Load of 34W(5W+11W+18W CFLs) Figure -Output voltage of Sine wave inverter with a load of 34W
30
March 13
Figure :-Time response of RMS value of the output voltage of the inverter
31
March 13
32
March 13
33
March 13
34
March 13
PLOT OF P Vs EFFICIENCY
35
March 13
36
March 13
CONCLUSIONS
The efficiency of the inverter is calculated by
considering different loads.The efficiency of the inverter is calculated by = Pac / Pdc The efficiency of the circuit varies between 75% to 88 %. The loads used are CFL and Bulb. The respective table shows the variation of terminal voltage and efficiency under different loads. The THD (Total Harmonic Distortion) is calculated by using the formula
37 March 13
CONTD.
The THD (Total Harmonic Distortion) is calculated by
n 2
Vn V1
The average THD IS 45%. b) The filter is recommended at the output of transformer .
38
March 13
FUTURE SCOPE
The
results obtained in the project should be verified by proper designing of the transformer. The inverter should be designed with DC-DC Converter as a charge regulator.
39
March 13
REFERENCES
S.P.Sukhatme and J.K.Nayak Solar Energy-Principles of Thermal Collection and Storage.TMH, 3rd Edition,2008 Gilbert M.Masters, Stanford University Renewable and Efficient Electric power System. John Wiley and Sons Ltd. ,3rd Edition.,2004 Chetan Singh Solanki Solar Photovoltaics Fundamentals, Technologies and Applications,PHI Learning Private Limited,New Delhi,2009. M.H.Rashid Power Electronics Handbook,Academic Press,pp 539-573. Tomas Markwart,Ed. Solar Electricity John Wiley and Sons Ltd. 2nd Edition,2004
Roger Messenger and Jerry Ventre Photovoltaic Systems Engineering CRC Press.,1999
Luis Castaner and Santiago Silvestre,Modelling of Photovoltaic Systems using Pspice.John Willey and Sons, Ltd.,2002 Mohan,Undeland and Robbins Power Electronics.John wiley and Sons Enhanced 3rd Edition.
40
March 13
REFERENCES
Publication on Standalone Photovoltaic Systems:
R. M. Moharil and P. S. Kulkarni, A case study of Solar Photovoltaic Power System at Sagardeep Island, India, International Journal Renewable and Sustainable Energy Reviews (Elseveir Publication), Vol. 13, 2009, pp. 673681.
Soib Taib,Yusmin Sutanto and Abd Rahim Abd Razak,Development of simple PWM inverter using photovoltaic cells,2002 student conference on Research and Development Proceedings,Shah alam,Malaysia.,pp.297300. A Ali Qazalbash,Awais Amin,Abdual Manan & Mahveen Kalid,Design and implementation of microcontroller based PWM technique for sine wave inverter,IEEE Conference POWERENG 2009,pp. 163-167.
S R Narayana Prakash,B S R Iyengar ,A new sinewavv inverter with high frequency link and synchronous rectification using power MOSFETs,Power electronics specialists conference,1990,PESC 90 Record,21 st annual IEEE,pp.923-928.
www.efymag.com
March 13
41
42
March 13
43
March 13