Escolar Documentos
Profissional Documentos
Cultura Documentos
INTRODUCTION
Application of biopsy in management of oral lesions has protocol
Patient follow up
3
What is a artifact?
Artefact refers to an artificial structure or tissue alteration on a prepared microscopic slide.
Co2 lasers are used for diagnostic biopsy THERMAL CYTOLOGICAL ARTEFACTS Electrocautery
Punch biopsy has been suggested to reduce the artefacts , although , it could not be confirmed under controlled experimental conditions.
5
Artefacts related to an incorrect handling of the specimens seem to be common in oral mucosal biopsy material.
No information is available on the performance of General dental practioners. Biopsy obtained from oral & maxillofacial surgeons.
No comparisons between the two groups have been described in the literature so far.
AIM
Investigate the artefacts produced in oral biopsy by GDP & O & MFs
The accomplishments of these objectives may contribute to define dos and donts when oral mucosal biopsies are performed by GDPs.
7
The incisional biopsies were carried out using a standard technique; a conventional elliptical biopsy was performed by scalpel.
Specimens were immediately introduced into a widemouthed container and fixed in a copious amount of 10% formol-buffered solution for 24 h.
All specimens were cut with a new disposable knife for every section and orientated before embedding in paraffin.
RESULTS
Oral mucosa was the most frequently biopsied area both by GDPs (75.1%) and O&MSs (62.7%). The biopsies by the GDPs were diagnosed as inflammatory disorders and oral precancer in up to 67.2% of the pathologists.
Most biopsies (65%) performed by O& MSs were diagnosed as benign or malignant tumoral disorders. 10
RESULTS CONT..
The most frequently identified artefact in GDPs (27.1%) and O&MSs (10.2%) biopsies was the crush. This artefact was more commonly found on inflammatory lesions.
The artefacts identified in GDPs biopsies were by frequency: crush 27.1%; haemorrhage 19.8%; splits 11.3%; and fragmentation 6.2%. No statistically significant differences in the proportion of artefacts were observed when the location of the original lesion was considered (P > 0.05).
11
RESULTS CONT..
General dental practioners Oral & maxillo facial surgeons CRUSH- 27.1 % CRUSH-10.2 %
HAEMORRHAGE- 19.8 %
HAEMORRHAGE- 8.5%
SPLITS 11.3%
SPLITS- 13%
FRAGMENTATION- 6.2%
FRAGMENTATION- 2.3%
12
RESULTS CONT..
EXCELLENT ( K > 0.75) , MODERATE ( 0.40 K 0.75), AND POOR ( K< O.40)
No autolysis or phenomena associated with inadequate tissue fixation were observed. Pathological diagnosis was not impaired in any of the cases by the improper surgical handling of the specimens.
13
DISCUSSION
Causes of artifacts :
Artefacts incurred during handling of tissue are a major source of diagnostic problems. Squeeze artefacts are a form of tissue distortion resulting from even the most minimal compression of tissue that groups crush, haemorrhage, splits, fragmentation and pseudocysts, and are usually caused by forceps, by using a stitch for traction or by a dull scalpel blade .
14
15
16
17
Handle tissue with care without pulling, or crushing. Minute specimen has to be kept on cardboard , prior fixation
Critical evaluation
Prefixation artefacts
Presence of sutures
Starch contamination
Necrosis due to monsels solution Cellulose contamination Gelfoam artefacts
Heat damage
19
Presence of sutures
Suture material is an occasional inclusion in histological specimens.It may consist of isolated fragments or complete fibre bundles cut in transverse , oblique or longitudinal planes. Silk sutures show strong birefringes under polarised light.
20
Starch contamination
Starch is used as a powder in surgical gloves and can therefore be deposited within or upon the surface of surgically acquired tissues. On occasions it may be present within granulomas removed surgically . Starch contamination can also occur in the labortary if new gloves are not washed before handling specimen. Starch stains very strongly with PAS stain and shows a characteristic Maltase birefringence with polarised light.
21
Cellulose contamination
Cellulose can be encountered as a contaminant arising from paper, cotton gauze used during specimen preparation.
23
Gelfoam artefacts
Gelfilm and gelfoam are used from absorbable gelatin and , in the form of a thin film or sponge , are used to control bleeding in various surgical procedures. They may be encountered in sections usually adhering to a specimen surface.
24
HEAT DAMAGE
Heat damage is seen along the margins of surgical biopsy. It takes the form of strong acidophilic staining in the local area with loss of nuclear & cytoplasmic detail. Connective tissue fibres become cougulated due to effects of heat and, if glandular tissue is present, it may become vacuolated. This artefact is caused by laser generated heat fixation of tissues.
25
YES
NO
CONCLUSION
2.
3.
4.
Summariz es clearly
5.
6.
7.
Results
26
References
JOSEPH E.et al, Artifacts in Oral Biopsy Specimens, J Oral Maxillofac Surg 43:163-172. 1985 Giuseppe Ficarra, Bonnie McClintock, Louis S. Hansen , Artefacts Created During Oral Biopsy Procedures, J. Cranio-Max.-Fac. Surg. 15 (1987) 34-37 Artifacts in histological and cytological preparation, Geoffery O rolls, Neville J farmer and john B hall.
27
for attention
28