Escolar Documentos
Profissional Documentos
Cultura Documentos
Mar 2008 Dr. B. C. Paul Note These slides contain screen shots and demonstrate procedures for the program MineSight by Mintec Inc. Similar procedure outlines can be found in some Mintec course material or presentations.
Set the Grid Set for Plan View and Accept Defaults Based on Our Project Area
First I click on the Green box to Attach the Gridset It then asks me Which gridset I left click to Highlight my Choice and Click ok.
I am about to enter the points around the edge of the dump surface
I will tell the Computer to Snap my points To the plane Of the edit grid
I Will Now Start Creating a Polygon for the top level surface of my dump
For My Organization I Will Create A Dump Slope Geometry Object and Put it in Edit Mode
Actually I dont think wed fill in a couple of places So I would probably go back and adjust my Dump lines if I were doing a design
Take each polygon area and multiply the area by 20 meters to get a volume in cubic meters Add the volumes up for the total volume The technique just described is called average end area (Minesight will do this automatically with one command once the surfaces problem is solved)
I can select either By picking in the Viewer On by picking from A menu The little blue worm is the Window pick Click it Then click on my General surface Then right click To complete my selection
Now I Will Select the Dump as my secondary surface in the same way