Escolar Documentos
Profissional Documentos
Cultura Documentos
ELECTRONICS II
BEE2233
IG =0A, therefore VRG = 0V
Therefore: VDS = VGS
Which makes VGS = V DD − I D R D
Feedback Biasing QPoint
• Plot the line using VGS = VDD, ID = 0 and ID = VDD / RD and VGS = 0
• Plot the transfer curve using VGSTh , ID = 0 and VGS(on), ID(on); all given in the
specification sheet.
• Where the line and the transfer curve intersect is the QPoint.
• Using the value of ID at the Qpoint, solve for the other variables in the bias
circuit.
DC analysis step for Feedback Biasing
Enhancement type MOSFET
• Find k using the datasheet or specification given;
ex: VGS(ON),VGS(TH)
• Plot transfer characteristics using the formula
ID=k(VGS – VT)2.
• Three point already defined that is ID(ON), VGS(ON)
and VGS(TH)
• Plot a point that is slightly greater than VGS
• Plot the linear characteristics (network bias line)
• The intersection defines the Q-point
VoltageDivider Biasing
Again plot the line and the transfer curve to find the Q
point.
Using the following equations:
R2VDD
Input loop : VG =
R1 + R2
VGS = VG − I D RS
Output loop :
VDS = VDD − I D ( RS + RD )
VoltageDivider Bias QPoint
• Plot the line using VGS = VG = (R2VDD)/(R1 + R2), ID = 0 and ID =
VG/RS and VGS = 0
• Find k
• Plot the transfer curve using VGSTh, ID = 0 and VGS(on), ID(on); all
given in the specification sheet.
• Where the line and the transfer curve intersect is the QPoint.
• Using the value of ID at the Qpoint, solve for the other variables
in the bias circuit.
Example
8
Solution
9
Solution
10
Discussion 1
11
Discussion 2
12
=-
=
=
= -
=-
= -
=
+
= -
= - ( + )
=
= -
=
+
= -
Design
For pchannel FETs the same calculations and graphs are used, except that the voltage
polarities and current directions are the opposite. The graphs will be mirrors of the nchannel
graphs.
Practical Applications
• VoltageControlled Resistor
• JFET Voltmeter
• Timer Network
• Fiber Optic Circuitry
• MOSFET Relay Driver
Test 1:
Tuesday Night 10 Feb 2009
Chapter 1 & 2 only
Lab 1:
1st week – Theory, simulation &
calculation
2nd week (now) – hardware experiment
3rd - hardware experiment
Thank You 4th week – writing final report &
submission
End of Chapter 2
18