Escolar Documentos
Profissional Documentos
Cultura Documentos
Start new files in the Drafting workbench. Generate views using the View Creation Wizard. Generate front views. Generate advanced front views. Generate projection views. Generate auxiliary views. Generate isometric views. Generate section views. Generate aligned section views. Generate offset section cuts. Generate aligned section cuts. Generate detail views. Generate detail view profiles. Generate clipping views. Generate clipping view profiles. Generate broken views. Chapter 13
Generate breakout views. Edit and modify drawing views. Modify hatch patterns of section views.
Chapter 13
Chapter 13
Chapter 13
The initial screen after starting a new file in the Drafting workbench
Chapter 13
Starting a New File in the Drafting Workbench Using the Start Menu
Menu: Start > Mechanical Design > Drafting
Chapter 13
TYPE OF VIEWS
Front View Projected View Section View Aligned Section View Auxiliary View
Detail View
Clipping View Broken View
Breakout View
Chapter 13
Chapter 13
Chapter 13
Preview of the front view at the lower-right corner of the geometry area
Chapter 13
Chapter 13
Chapter 13
Chapter 13
Chapter 13
Chapter 13
The front view generated using the Advanced Front View tool
Chapter 13
Projected view (Top view) generated from the front view using the Projection View tool
Chapter 13
Chapter 13
Chapter 13
Chapter 13
Chapter 13
Chapter 13
Chapter 13
Chapter 13
Chapter 13
Chapter 13
Chapter 13
Detail view
Chapter 13
Chapter 13
Clipping view
Chapter 13
Chapter 13
Chapter 13
Chapter 13
Chapter 13
Chapter 13
Chapter 13
Chapter 13
TUTORIAL 1
In this tutorial, you will generate the drawing views of the model of the Motor Cover created in tutorial 2 of chapter 8, refer to Figure A.
Chapter 13
Chapter 13
Chapter 13
5. Generate the top view by using the Projection View tool, refer to Figure C.
Chapter 13
6. Generate the aligned section view from the top view after activating it, refer to Figures D and E.
Chapter 13
Figure E The drawing sheet after generating the aligned section view
Chapter 13
TUTORIAL 2
In this tutorial, you will create the Bench Vice assembly and then generate the front, top, right, and isometric views of the Bench Vice assembly, as shown in Figure A. Figures B through E show the views and dimensions of the components of the Bench Vice assembly
Chapter 13
Chapter 13
Chapter 13
Orthographic views and dimensions of various components of the Bench Vice assembly
Chapter 13
Figure E Orthographic views and dimensions of various components of the Bench Vice assembly
Chapter 13
The following steps are required to complete this tutorial: 1. Create all components of the Bench Vice assembly and assemble them. 2. Start a new file in the Drafting workbench using the A2 size sheet. 3. Set the standard of the projection to third angle. 4. Generate the front view, refer to Figure F.
Chapter 13
Chapter 13
Chapter 13
Chapter 13
Figure I Final drawing sheet after generating all the drawing views
Chapter 13