Escolar Documentos
Profissional Documentos
Cultura Documentos
Security Level:
www.huawei.com
Huawei Confidential
Function description and main interface
introduction
Operation step introduction Analyze result introduction Simple version introduction Application example
Huawei Confidential
Page 3
Huawei Confidential
Page 4
Huawei Confidential
Page 5
Main interface
Huawei Confidential
Page 6
2 Operation step
Mainly introduce construct package and send
package setup(use ICMP as example)
Huawei Confidential
Page 7
2 Operation step
Step 2:set package head
Set mac parameter MAC DA:destination MAC Set SA:source IP parameter MAC MAC DSCP:set IP priority Normal not modify, use Identifier:set the begin ID the address inspect by the of IP toolVLAN if you need to Flags:set IP s flag construct package with Time to live:set IPs vlan, then input VLAN TTL ID ICMP Protocol:set the type of Priority set VLAN priority Type:select ICMP protocol of IPs payload Ether type up layer type,also can select from Check sum set heck protocol type dropdownlist sums value Code:set the code value of Source IPs source ICMPIP:set package address, can the select Check also sum:set check from the dropdownlist sum of ICMP Destination IP:set the Identifier:set the ID value destination address of IP of ICMP Sequence:SET the begin sequence value of ICMP
Huawei Confidential
Page 8
2 Operation step
Step 3:select network card
Select from the dropdownlist of Device
Huawei Confidential
Page 9
2 Operation step
Setp 4:set the sending parameter
Statistic:send package,and Constant rate:select from the count the sending rate dropdownlist, max is 5M Bps Packet pour/not stat:only send Custom rate:set the the number package,not count sendof rate package Repeat ,sent interval information Break,sizePkSizeto set the send rate In Time/s:set the sending total Send rate (bps)= time In Num:set the sending times
Huawei Confidential
Page 10
2 Operation step
Step 5:begin send package
Package send information New:the delay of the latest package send Max:the max delay Min:the min delay Mean:average delaySend:sent package count Receive:received package count Drop:discard package count You can view the count of package after stop send Begin send
Huawei Confidential
Page 11
2 Operation step
Typical configuration
21M bps: Repeat:500 Break:100 PktSize1000 42M bps: Repeat:1300 Break:100 PktSize1400
Huawei Confidential
Page 12
Huawei Confidential
Page 13
Huawei Confidential
Page 14
Huawei Confidential
Page 15
5 application example
1:one office need to test the QoS of IUB with vlan configuration Test process:use two PC instead of RNC and NodeB, execute ping to check the package delay and lose condition step
Huawei Confidential
Page 16
5 application example
2one office ps traffic rate is low, and doubt the limitation of transmission network Trouble shouting process:use this tool to test ,the rate can only reach 5Mbps
step
1 copy the tools to PC 2 set send parameter of according to request,view the rate,find the fast rate by gradually change the send flux
Huawei Confidential
Page 17
Thank you
www.huawei.com