Escolar Documentos
Profissional Documentos
Cultura Documentos
By
Aditya Singh
Vishnu Mhalaskar
Akash Patil
Deepak Maurya
Guide
D. G. Pandit Sir
The segway is a two wheeled, self balancing, battery-powered electric vehicle . The
name Segway is derived from the word segue, meaning smooth transition.
The Segway personal transporter is a small footprint electrical vehicle
designed to replace the car as a more environmentally friendly
transportation method in metropolitan areas. The dynamics of the
vehicle is similar to the classical control problem of an inverted
pendulum, which means that it is unstable and prone to tip over. This
is prevented by electronics sensing the pitch angle and its time
derivative, controlling the motors to keep the vehicle balancing
This kind of vehicle is interesting since it contains a lot of technology
relevant to an environmentally friendly and energy efficient
transportation industry. This thesis describes the development of a
similar vehicle from scratch, incorporating every phase from literature
study to planning, design, vehicle construction and verification. The
main objective was to build a vehicle capable of transporting a
person weighing up to 100 kg for 30 minutes or a distance of 10 km,
whichever comes first. The rider controls are supposed to be natural
movements; leaning forwards or backwards in combination with tilting
the handlebar sideways or by pressing the button on the handlebar
should be the only rider input required to ride the vehicle.
Segways perform best in areas with adequate
sidewalks, curb cuts at intersections, and ramps.
They are used in some theme parks by visitors
and employees.
They are used by Cops for patrolling purpose.
They are also used in some malls by attaching
a trolley behind it.
They can be used for Domestic purposes at
Home.
FEATURES:
Easy to build with no welding, no complicated steering
linkage and minimal soldering.
Uses a readily available $3 digital MPU6050
accelerometer/gyro IMU (Inertial Measurement Unit) board.
Total parts cost is under $250, A real Segway is $5000!
No salvage, dumpster diving or Craigslist parts.
Uses the very common Arduino UNO processor board.
COMPUTER, SENSORS, and ELECTRIC MOTORS in the base of
the SEGWAY PT keep the device upright when powered on
with balancing enabled. The rider commands the PT to go
forward or backward by shifting their weight forward or
backward on the platform.
The Segway uses GYROSCOPIC SENSOR and
ACCELEROMETER based levelling sensors to detect the
resulting changes in its pitch angle and, to maintain
balance, it drives its wheels forward or backward as
needed to return its pitch to upright.
In the process, the rider establishes and then
maintains a desired speed by modulating the extent
and duration of their fore/aft weight shifts. To turn
and steer, the rider presses the MOMENTARY ROCKER
SWITCH to the left or right. The PT responds by
adjusting the speeds of the wheels in opposite
directions causing the PT to yaw and, if not traveling
forward or backward, turn in place.
At speed, the amount of shift of the MOMENTARY
ROCKER SWITCH corresponds to the amount of left
or right lean required by the rider to balance
themselves on the platform during a turn.
Become more productive: more work can be done by using the
product versus walking
Become more recognizable: Riders stand an additional eight
inches off the ground, allowing you to be better seen and
giving the rider better sight lines, over cars in a parking lot or
boxes in a warehouse.
Low operating costs: no need for gas and inexpensive battery
charging (A complete cycle charge will take eight to ten hours)
Reduce fatigue caused by walking
A clean, green, eco-friendly machine! (zero emission)
Main Components :