Escolar Documentos
Profissional Documentos
Cultura Documentos
Contains:
Modular Construction Contains
Input Switch/Circuit Breaker
Mother Board NPPB
Monitor/ Control card NPSJ
Inverter card NPID
P15/N15 Regulator card NPSK
Specification:
Input : Nominal 115 V rms (
103-127 V)
Frequency – 47 to 63 Hz (
Single Phase)
Multiple Outputs :
28 V DC / 3.5 A Unregulated
Regulated 5 V DC/15 A, +/- 15 V
DC/1.5 A
NPSP :This card is intended to be used in power
supply Psff . it contains under voltage detector,
bleeder resistor for the unregulated P28 and rectifier
diodes. the card itself is incomplete, therefore it cannot
function independently PTH means copper plated
through holes. These holes are used for end to end
connection means to make tracks. Connector we are
using in NSFC module is made by GE notch at the
both corner .
NPPB – This is a mark IV power supply mother
card. Three daughter board (NPSJ,NPID,NPSK)
incorporate the mother card NPPB,into a
power supply module (PSCB) with output
5V,20 AMP,±15 V,1AMP.
Functions:
• Signal Conditioning
• Connection for inter panel and customer wiring ( Through
TB’s)
Construction:
• Backplane Boards – 2 Nos. XBPH and
XBPG – Provides interconnecting wiring
• Input Boards ( HRIA ) – 2 Nos.
• Output Boards ( HROA) – 2 Nos.
• Power Supply - DPSA
DPSA (105 V ) Power Supply
Provides 105 V DC for input contacts
Includes
• Short Circuit Output Protection
• Fused Input Protection
Function:
•Controls firing of power converters and
field converters which are connected in
Source / Load for driving motor.
• Microcomputer for implementation of
control algorithm
• Contains L bus and R bus.
Input Signal Conditioning (HISA) Module Functions:
• On Board Memory
insulation sheet
• NTRF – Improved heat sink mounting to take
Perspex sheet
• Provision of CAUTION CMOS Label on VFD