Escolar Documentos
Profissional Documentos
Cultura Documentos
• INTRODUCTION
• OBJECTIVE
• LITERATURE REVIEW
• EXPERIMENTATION AND MEASUREMENTS
• RESULTS AND DISCUSSION
• CONCLUSION
• FUTURE SCOPE
• REFERENCES
INTRODUCTION
• In ‘blind 'milling the depth is not a set parameter but a critical variable
which depends upon material properties, cutting power and speed.
• The shorter the wavelength, the better the light absorptivity for metal.
• The higher the wavelength, the better the light absorptivity for polymer.
OBJECTIVE
The present work has been show to investigate blind pocket micro-milling
(Raster mode) performance on two different material titanium as a low
conducting metal and acrylic as a polymer, with different parameters, namely
laser power, cutting speed and number of scan and compare experimental
values with theoretical one.
LITERATURE REVIEW
Design of blind
1. Vernier caliper-For depth measurement pocket(10*10mm2
2. Optical microscope-For micro level images and 5*5mm2)
3. Mechanical Profilometer-For roughness of milled surface
Roughness
Table For metal: Titanium
Power Factor Velocity Factor Number 𝑅𝑎 (𝜇𝑚) 𝑅𝑧 (𝜇𝑚) 𝑅𝑞 (𝜇𝑚)
of scan
0.3867 0.993
70 0.34 0.35 0.36 0.4104 17.25 1.2313 26.06 0.98 0.97 0.98
0.35 0.9767
50 0.17 0.19 0.2 0.293 56.93 0.879 59.81 0.55 0.56 0.54
0.1867 0.55
30 0.09 0.11 0.12 0.1758 64.76 0.5276 93.04 0.27 0.27 0.28
0.1067 0.2733