Escolar Documentos
Profissional Documentos
Cultura Documentos
Introduction
SR Vincent Consulting Crown Works BPV Dentalsmith Dental Health Center Dentalsmith Labs
Introduction
Labs and the industry Impressions and how they are used Good, bad and the ugly Trade secrets Q&A
Best Practices
The Bite Mantra
After the prep Before the impression
Ensure the opposing and endentulous NEVER trim the bite registration
Best Practices
Basics
Light body, med body Get enough of the arch Get the palette Passive bite or clinched bite Dont clinch especially with provisionals in Opening a bite get an open impression
Best Practices
About taking shades
Get the numbers Stump shades if dramatically different Blockout noted prn
Best Practices
Tricky Setups
Free end quadrants Endentulous bites
Best Practices
Specials Circumstances
Post and core
Best Practices
Specials Circumstances
Implant impressioning
Best Practices
Specials Circumstances
Provisionalization
Best Practices
Cautions
Remove the bumpers Temp Control For every 2 degrees of storage temp above 72 you loose 20% of your working time and have an accelerated set
Best Practices
Cautions
Slow and even Dont load the tray too early Dont load the tray too slowly All injection and insertion should be completed at least 1 min before working time expires
Best Practices
Cautions
Burp your tubes and tips Never use an un-supported tray Sulfur or talc will retard or prevent the set of many synthetic impression materials
Best Practices
Pouring your own models
Let the impression breathe at least 30 minutes prior to pouring modelwork
Best Practices
Pouring your own models
Thick enough Dont dome them Flipping them is good
Things to Remember
Temperature controls Dont hyper extend the mandible Know your materials Ask questions before you trainwreck
Things to Remember
Check the labwork upon receipt If it fits the model it fits If it doesnt fit the mouth the impression was bad