Escolar Documentos
Profissional Documentos
Cultura Documentos
Smallest, Lowest-Cost
RFI Power Line Filters
for SMPS Emission Control
SK7
UL Recognized
CSA Certified SK1
VDE Approved
SK3
SK Series – 3, 6 & 10 Amp Models Specifications
This series of RFI filters was designed to reduce Maximum leakage current, VSK Models ESK Models
conducted noise to acceptable limits for equipment that each line-to-ground
must comply with the FCC specifications in the USA and @ 120 VAC 60 Hz: .4 mA .21 mA
CISPR specifications in Europe. @ 250 VAC 50 Hz: .7 mA .36 mA
Hipot rating (one minute):
The SK (Super K) series filters use significantly higher
line-to-ground 2250 VDC
element values than the general purpose K series, which
line-to-line 1450 VDC
makes them better suited for equipment with line-to-
ground and line-to-line conducted emissions, including Operating frequency: 50/60 Hz
switch mode power supplies. Rated voltage: 120/250 VAC
The ESK models meet the very low leakage current Rated current: @120 VAC @ 250 VAC
requirements of VDE portable equipment and (120 Volt) 3VSK/3ESK 3A 3A
UL 544 nonpatient medical equipment. 6VSK/6ESK 6A 5A
10VSK/10ESK 10A 8A
Maximum current rated peaks:
Electrical Schematic 3VSK/3ESK 10A
6VSK/6ESK 18A
10VSK/10ESK 30A
VSK
3A, 6A, 10A 4 23 25 29 43 44 42 42 30
ESK
3A, 6A, 10A 4 22 24 28 42 40 36 36 27
Tolerance: ±
.005
0.13
Typical dimensions
.0 7 .07 x .16
Terminals: .250 (3) Holes: Dia.(2) Slot:
6.35 1.8 1.8 x 4.1
Panel Cutout (back mount)
Libertyville, IL (847) 680-7400