Escolar Documentos
Profissional Documentos
Cultura Documentos
Comandos Basicos Cisco
Comandos Basicos Cisco
Switch> ena
Switch(config)# hostname S1
S1(config)# exit
S1 # write
PONER CONTRASEÑA
S1 > enable
S1 # configure terminal
S1 (config-line)# login
Copiar a la NVRAM
CONFIGURACION S2
Switch> ena
Switch(config)# hostname S2
S2(config)# exit
S2 # write
PONER CONTRASEÑA
S2 > enable
S2 # configure terminal
S2 (config-line)# login
Copiar a la NVRAM
Router>ena
Router#conf term
Router(config)#hostname R1
R1(config)#line console 0 4
R1(config)#login
R1(config)#password cisco
Interfaces
R1#conf terminal
R1(config)#interface gigaR1
R1(config-if)#exit
R1(config-subif)#encapsulation dot1Q 10
R1(config-subif)#enca
R1(config-subif)#encapsulation dot1Q 20
R1(config-subif)#ip address 192.169.1.1 255.255.255.248
R1(config-subif)#exit
R1(config-subif)#ENCASU
R1(config-subif)#en
R1(config-subif)#encapsulation dot1Q 10
R1(config-subif)#ip address 192.168.1.9 255.255.255.248
R1(config-subif)#
R1(config-subif)#
R1(config-subif)#exit
R1(config)#interface Loopback 0
R1(config-if)#
%LINK-5-CHANGED: Interface Loopback0, changed state to up