Escolar Documentos
Profissional Documentos
Cultura Documentos
Uma dobradiça é um mecanismo que segura e gira uma parte (móvel) fixada na
lateral do móvel. Normalmente, possuem duas pequenas placas metálicas
articuladas por meio de um eixo ou pino preso por parafusos que facilitam sua
ativação. As dobradiças são usadas principalmente em portas, mas podem ser
usadas para outros usos.
• Eles são muito baratos. O custo por par os coloca ao alcance de qualquer
orçamento.
• Eles permitem ajustar a posição da porta, isso é muito importante no caso
de armários de cozinha ou armários onde existem várias portas próximas
umas das outras.
• São utilizados para portas sobrepostas ou no interior do móvel.
• Permitem a abertura da porta em grande ângulo (ângulo mínimo 90°).
• Eles fazem a porta fechar sozinha.
• Permite fácil substituição em caso de deterioração.
• Suporta grandes pesos devido ao seu sistema.
Partes de uma dobradiça bidimensional
Se o que você deseja é colocar uma dobradiça do zero em uma porta que não
tenha perfurações, você deve ter clareza sobre as medidas necessárias onde
fará o furo para a dobradiça, a distância entre elas e outros fatores importantes
que explicamos abaixo . Mas antes, listo os elementos necessários para poder
realizar este trabalho:
CO NFI G URAT I O N
Cut the toekick out of the bottom front corners of all three side panels (23.25" x
34.5"). My standard toekick is 4" x 4" - but this can be altered to fit utilities, vac
systems, or to match baseboards.
Drill four 3/4" pocket holes on the left bay bottom shelf ends and attach to side
panels with 1-1/4" pocket hole screws, so bottom edge matches top edge of
toekick.
LE FT BAY S UP P ORT S
Strengthen the carcass by adding bay supports to the top, back and bottom of
the left bay as shown. Bay support length is equal to your bay width and shelf
board lengths. Attach with 3/4" pocket holes and 1-1/4" pocket hole screws. All
pocket holes should be placed on outside to hide and for greatest strength.
NOTE: Bottom bay supports should be held flush to bottom shelf, and do NOT
need to fully extend to the bottom of the cabinet. A front toekick trim piece will
cover any gaps on final install.
ADDI NG T HE RI GHT BAY
On right bay shelf, drill four pocket holes on each end of the shelf on 3/4"
setting.
Attach the bottom shelf to the remaining side panel and the bottom shelf of the
main left bay carcass with 1-1/4" pocket hole screws.
Add bay supports at the top equal to your right bay shelf length with pocket
holes. A back bay support is also recommended.
Bottom bay supports are required to strengthen the bottom shelf up. Measure
and cut and attach to the bottom.
O P TI O NAL S HE LVE S
Optional shelves can be added inside with pocket holes. If using a lazy susan
or similar, you can skip the shelves.
ADDI T I O NAL CO UNT E RT O P S UP P ORT
If you have a countertop that seams in the corner (not a solid piece), you can
further strengthen the corner as shown below with a 2x2 or similar.
DO O RS
For the doors, measure the openings and order doors as follows:
The hinges you will need are called "Frameless BiFold Hinge Kit" - they can
also be called "pie corner" hinges. It is important to order frameless for this
template. There should be a total of four hinges in the kit, two per each door.
Here is an example of the needed hinges.