Escolar Documentos
Profissional Documentos
Cultura Documentos
Autores
Enio Bueno Pereira
Fernando Ramos Martins
Samuel Luna de Abreu
Ricardo Rther
Realizao
Diviso de Clima e Meio Ambiente - DMA
Centro de Previso de Tempo e Estudos Climticos - CPTEC
Instituto Nacional de Pesquisas Espaciais - INPE
Ministrio da Cincia e Tecnologia - MCT
Patrocnio
Programa das Naes Unidas para o Meio Ambiente - PNUMA
Fundo Global para o Meio Ambiente (Global Environment Facility) - GEF
Projeto SWERA - Solar and Wind Energy Resources Assessment
620.91
ISBN 85-17-00030-7
ISBN 978-85-17-00030-0
parte apresenta alguns cenrios de utilizao desses recursos no Brasil. ASRC - Atmospheric Sciences Research Center / State
University of New York at Albany - USA
E ste trabalho contou com contribuio das instituies listadas abaixo: DLR - German AeroSpace Center
ASRC - Centro de Pesquisa em Cincias Atmosfricas / NREL - National Renewable Energy Laboratory - USA
Universidade Estadual de Nova York, campus Albany - EUA TERI - The Energy and Resources Institute - India
DLR - Centro Aerospacial Alemo
NREL - Laboratrio Nacional de Energias Renovveis - EUA
W e hereby thank the decisive and continued support provided by
INPE by means of its Climate and Environment Division of the Center
TERI - Instituto de Recursos Energticos - ndia for Weather Forecasts and Climate Studies and its Environmental
Introduo 9 Introduction 9
Nveis de confiabilidade das estimativas de irradiao solar 25 Reliability levels of solar irradiation estimates 25
Intercomparao de modelos 25 Model inter-comparison 25
Comparao com dados coletados em superfcie 26 Comparison with ground data 26
Validao da irradiao global 26 Validation of global radiation 26
Validao da DNI 28 Validation of DNI 28
O T
aumento da demanda energtica em conjunto com a
possibilidade de reduo da oferta de combustveis convencionais e a
crescente preocupao com a preservao do meio ambiente esto
he increase in energy demand in conjunction with the possibility
of a reduction in the supply of conventional fuels and the increasing
concern with preserving the environment are driving the scientific
9
impulsionando a comunidade cientfica a pesquisar e desenvolver community to research and develop alternate energy sources that
fontes alternativas de energia menos poluentes, renovveis e que are less polluting, renewable and have a lesser impact on the
produzam pouco impacto ambiental. environment.
A Figura 1a apresenta a
estrutura da matriz de oferta
F igure 1a shows the matrix
structure of the primary
de energia primria brasileira e Brazilian energy supply and
a Figura 1b a empregada na Figure 1b the energy matrix
produo de eletricidade. A used in the production of
queima de combustveis fsseis electricity. The fossil fuels is
responde por grande parte da responsible for great part of
demanda de energia no setor the energy demanded by the
de transporte e atende a cerca transportation sector and
de 40% da energia utilizada no provides about 40% of the
setor agropecurio brasileiro energy used by the Brazilian
causando a contribuio mais farming sector. Incentive
importante em emisso de programs to adopt the bio-
gases do efeito estufa (CO2, . (a) Matriz energtica brasileira . (a) Brazilian energy matrix mass fuels (ethanol and
CO, etc.) no Brasil. Programas e (b) Matriz de energia eltrica [2]. and (b) Electric power matrix [2]. biodiesel) are being imple-
de incentivo para adoo de mented in the country [2] and
queima de biomassa (etanol e biodiesel) esto em implementao no it is expected that in a not too distant future, biomass will make a
pas [2] e espera-se que num futuro prximo, a biomassa tenha uma significant contribution towards these sectors thereby reducing the
contribuio significativa nesses setores reduzindo a contribuio Brazilian contribution for the global emission of gases that cause the
brasileira para a emisso global de gases de efeito estufa. greenhouse effect.
A tualmente, a energia hidrulica a principal fonte de energia para P resently, hydroelectric power is the main source of power
Atlas Brasileiro de Energia Solar
gerao de eletricidade no Brasil. Apesar de ser considerada uma fonte generation in Brazil. In spite of being considered a renewable and
renovvel e limpa, as usinas hidroeltricas produzem um impacto clean source of energy, the hydroelectric power plants cause an
ambiental ainda no adequadamente avaliado, devido ao alagamento impact on the environment not yet fully assessed, due to the flooding
de grandes reas cultivveis [3]. Estudos mostram que gases do efeito of vast agricultural or pristine forested areas [3]. Studies show that
estufa, principalmente o Metano (CH4), so emitidos para atmosfera em greenhouse gases, mainly methane (CH4), are released into the
conseqncia de processos de degradao anaerbica da matria atmosphere as a consequence of the anaerobic decomposition of
orgnica que ocorrem em reas alagadas [4]. Alm disso, as principais organic matter that takes place in flooded areas [4]. In addition, the
bacias hidrogrficas brasileiras com capacidade de gerao hidroeltrica main hydrographic basins suitable for high-density hydroelectric
de alta densidade energtica j esto praticamente esgotadas nos power generation have practically all been used up primarily the
principais centros consumidores do Pas. ones near to the main Brazilian consumption centers.
A s perspectivas e oportunidades de aproveitamento do potencial T he outlook and opportunities for harnessing the economic
econmico relacionado com a explorao comercial dos recursos
energticos da radiao solar dependem basicamente de dois fatores:
1) do desenvolvimento de tecnologia competitiva de converso e
potential related to the commercial exploitation of energy resources
of solar radiation basically depend on two factors: 1) the
development of a competitive conversion and storing technology for
11
armazenamento dessa energia; e 2) de informaes seguras e da this energy; and 2) the availability of reliable information linked to
poltica energtica do pas. Grande parte dos potenciais investidores e the energy policy of the nation. A great portion of the potential
produtores do setor energtico no dispem de informaes nem de investors and stakeholders in the energy sector do not have
conhecimento, com o embasamento cientfico necessrio, sobre as information or knowledge available, on a solid scientific basis, about
opes em fontes renovveis de energia e, por conta disso, tendem a their options with regards to renewable sources of energy and for
evitar os riscos econmicos e financeiros associados ao that reason they tend to avoid economic and financial risks
desenvolvimento de projetos nessa rea. De um modo geral, as associated with projects in this area. In general, the required
informaes de carter cientfico necessrias so: scientific information consists of:
o levantamento em alta resoluo espacial do potencial a high resolution space survey of the solar energy potential;
energtico solar; long time series of ground data with temporal and spatial
sries temporais de longa durao de dados de campo com resolutions adequate for the analysis of uncertainties and
resolues temporais e espaciais adequadas realizao de trends;
estudos de incertezas e tendncias; knowledge about the variability of these renewable sources
conhecimento sobre a variabilidade dessas fontes renovveis as they relate to natural and man-made factors.
O
associada fatores naturais e antropognicos.
a obteno das estimativas de irradiao solar: o modelo de solar radiation maps: the radiative transfer model, its input database,
transferncia radiativa, a base de dados de alimentao do modelo e o and the validation process of the estimates provided by this method.
processo de validao das estimativas por ele fornecidas. Em seguida, Afterwards, the results of the annual and seasonal averages of the
os resultados das mdias anuais e mdias sazonais das diversas various solar irradiation components as well as the variability
componentes da irradiao solar bem como a variabilidade associada a associated to each one of them will be presented and discussed. At
cada um deles sero apresentados e discutidos. Ao final sero the end graphs showing the power availability trends for every region
apresentados grficos de tendncias da disponibilidade de potncia of Brazil will be presented with a brief discussion of various scenarios
para cada regio do Brasil e uma breve discusso de cenrios de uso de for the use of solar energy in Brazil.
energia solar para o Brasil.
12
Atlas Brasileiro de Energia Solar
MODELO DE TRANSFERNCIA RADIATIVE TRANSFER MODEL
RADIATIVA
A s nuvens, os gases,
partculas atmosfricas e a
T he clouds, the gases,
atmospheric particles, and
superfcie refletem cerca the surface reflect about
de 30% da radiao inci- 30% of the radiation inci-
dente no topo da atmos- dence at the top of the
fera. Os 70% restantes so atmosphere. The other
absorvidos produzindo 70% are absorbed in hea-
aquecimento do sistema e ting up the system and
causando evaporao de causing water evaporation
gua (calor latente) ou (latent heat) or convection
conveco (calor sensvel). (sensible heat). The energy
A energia absorvida pelo absorbed by the Earth-
sistema Terra-Atmosfera Atmosphere system is re-
reemitida na faixa do emitted back to space in
infravermelho do espectro the infrared spectrum band
14 de radiao eletromag-
ntica 4 a 100m
sendo que 6%
of electromagnetic radia-
tion - 4 to 100m - where
6% comes from the surface
proveniente da superfcie . Diagrama simblico dos processos . Diagram of radiative processes of and 64% from clouds and
e 64% tem origem em de interao da radiao solar com a solar radiation in the Earth's atmosphere. other atmospheric com-
nuvens e constituintes atmosfera terrestre. Os valores numricos The numeric values represent the energy ponents.
atmosfricos. representam a frao de energia em cada fraction in each radiation process in the
15
O modelo BRASIL-SR um modelo
fsico para obteno de estimativas da T he BRASIL-SR model is a physical
radiao solar incidente na superfcie model to obtain solar radiation
que combina a utilizao da incidence estimates on the surface that
aproximao de Dois-Fluxos na combines the "Two-Stream" approach
soluo da equao de transferncia to solve the radiative transfer equation
radiativa com o uso de informaes along with climate data and satellite
climatolgicas e parmetros images [13]. The BRASIL-SR model is
determinados a partir de imagens de based on the IGMK model originally
satlite [13]. O modelo BRASIL-SR foi developed at the GKSS
desenvolvido com base no modelo Forschungszentrum and described by
IGMK de autoria de pesquisadores do Stuhlman et al. [14]. Figure 4 shows the
GKSS Forschungszentrum e descrito flowchart of procedures carried out to
por Stuhlman et al. [14]. A Figura 4 obtain solar radiation estimates using
mostra o fluxograma dos procedi- the BRASIL-SR model. This procedure
. Fluxograma do . Flowchart of the is divided into three phases:
mentos executados para obteno das modelo de transferncia BRASIL-SR radiative transfer
estimativas de irradiao solar radiativa BRASIL-SR. model.
utilizando o modelo BRASIL-SR. A
obteno da estimativa do fluxo de assimilation of climate and satellite data;
radiao solar incidente na superfcie dividida em trs etapas: solution of the radiative transfer equation using the "Two-
tratamento dos dados climatolgicos e das imagens de satlite; Stream" approach [15];
soluo da equao de transferncia radiativa utilizando a calculation of each solar radiation components (global, direct
aproximao de Dois-Fluxos [15]; and diffused).
clculo de cada uma das componentes do fluxo de radiao
solar (global, direta e difusa). T he assimilation phase has the purpose of preparing the required
A
Atlas Brasileiro de Energia Solar
D ,
essa forma, o fluxo de radiao solar global incidente na superfcie,
pode ser obtido a partir de:
obtained from:
16 g
where 0 is the radiation flux at the top of the atmosphere, tclear and
onde 0 a radiao incidente no topo da atmosfera, tclear e tcloud tcloud are respectively the atmospheric transmittance for clear and
so as transmitncias atmosfricas em condies de cu claro e overcast sky conditions and Ceff is the effective cloud cover index
completamente nublado, respectivamente, e Ceff a cobertura efetiva given by the satellite images:
de nuvens dada pelas imagens de satlite:
L - Lclear
L - Lclear Ceff =
Lcloud - Lclear
Ceff =
Lcloud - Lclear
T he instantaneous readout obtained for a satellite image pixel is
A leitura instantnea obtida para um pixel da imagem do satlite est
representada por L e os ndices clear e cloud referem-se leitura em
represented by L and indices clear and cloud refer, respectively, to
readings in clear and overcast skies.
condies de cu claro e de cu encoberto por nuvens, respectivamente.
I n that way, the incidence of global solar radiation at the surface may
D essa forma, a determinao do fluxo de radiao solar global
incidente na superfcie pode ser estimada a partir de duas componentes
be estimated from two independent components: the first component
corresponds to clear sky condition, tclear, and the second to a
independentes: a primeira componente corresponde condio de completely overcast, tcloud . The random nature of solar radiation for
cu claro, tclear, e a segunda refere-se condio de cu totalmente any sky condition is evaluated through the effective cloud cover index,
encoberto, tcloud . A natureza estocstica do fluxo de radiao solar em Ceff . The tclear component is a function of the surface albedo, the solar
qualquer condio de nebulosidade avaliada atravs do coeficiente zenithal angle and the optical thickness of the atmosphere. The tcloud
de cobertura efetiva de nuvens, Ceff . A componente tclear funo do component is a function of the solar zenithal angle, the optical thickness
albedo de superfcie, do ngulo zenital solar e da espessura tica dos and optical cloud properties. The two components may be estimated
constituintes atmosfricos. A componente tcloud funo do ngulo from the parameterization of the well-known physical processes by
using climate data. To determine the transmittances tclear and tcloud,
zenital solar, da espessura tica e de propriedades ticas das nuvens. As
duas componentes podem ser estimadas a partir de parametrizao dos the model uses 135 spectral intervals in the shortwave spectra (0 4m)
processos fsicos bem conhecidos que ocorrem na atmosfera utilizando and adopts 30 atmospheric layers to solve the radiative transfer equation.
(1 - tc)
tcloud-dir = ..................
where
{ tc = (CCI + 0,05) if CCI < 0,95
tc = 1,0 if CCI
(b - tc)
T he transmittance tatm-dir refers to radiative processes involving
aerosols and atmospheric gases in a clear sky condition. This
onde
{ tc = (CCI + 0,05) if CCI < 0,95
tc = 1,0 if CCI
transmittance is estimated through the solution of the radiative transfer
equation using the "Two-Stream" approach.
18
Atlas Brasileiro de Energia Solar
BASE DE DADOS DATABASE
ALBEDO DE SUPERFCIE
SURFACE ALBEDO
A base de dados de albedo utilizada neste T he albedo database used in the development
of this Atlas was obtained through the model
trabalho foi obtida atravs do modelo
desenvolvido por Sellers et al. [20] que calcula o developed by Sellers et al. [20] which calculates
albedo de superfcie em vrios intervalos the surface albedo for various spectral intervals.
espectrais. Esse modelo alimentado por This model is fed by measurements obtained by
medidas do ndice de Vegetao por Diferena satellite of the "Normalized Difference
Normalizada (IVDN) obtidas por satlite e Vegetation Index (NDVI) and other biophysical
outros parmetros biofsicos relacionados ao parameters related to the type of vegetation [21].
tipo de vegetao [21]. Assim, os dados obtidos The data obtained for the surface albedo
para o albedo de superfcie representam valores represent average monthly values during the day
mdios mensais durante o ciclo diurno. Essa cycle. This database is available in
base de dados est disponvel em . Mapa da . Map for ftp://daac.gsfc.nasa.gov/ and it is supplied in
ftp://daac.gsfc.nasa.gov/ e fornecida na forma mdia anual de annual mean of form of a regular grid with a 1 x 1 resolution.
albedo de superfcie surface albedo Figure 8 shows, as an illustration, the map of the
de uma grade regular com resoluo 1 x 1.
obtido por obtained using the annual average of albedo produced at the same
A Figura 8 apresenta, a ttulo de ilustrao, o interpolao de nearest neighbor
mapa da mdia anual de albedo produzido na spatial resolution of the GOES-12 satellite
vizinho mais interpolation
mesma resoluo espacial das imagens do images using the nearest neighbor
prximo. technique.
satlite GOES-12 utilizando o mtodo do interpolation method.
vizinho mais prximo para a interpolao.
UMIDADE RELATIVA RELATIVE HUMIDITY
A T
Atlas Brasileiro de Energia Solar
24 . Nmero de PCD
utilizadas para validao do
modelo BRASIL-SR.
. The AWS sites used
to validate solar data
provided by the BRASIL-SR.
A
Raumfahrt [28].
comportamento dos modelos em relao parametrizao dos processes for clear sky conditions. The Balbina site is located close to
processos radiativos tpicos de condies de cu claro. A estao de the hydroelectric power plant of the same name in the Amazon region.
Balbina est localizada prximo usina hidroeltrica de mesmo nome The climatology of the region is strongly influenced by the Inter-tropical
na regio amaznica. A climatologia da regio fortemente Convergence Zone (ITCZ), with a high precipitation and a few clear sky
influenciada pela Zona de Convergncia Intertropical (ZCIT), sendo days throughout the year. The Florianpolis site already reached the
que a precipitao pluviomtrica elevada e a quantidade de dias de established requirements by the BSRN (Baseline Solar Radiation
cu claro pequena ao longo do ano. A estao de Florianpolis j Network) network for collection and qualification of ground data. The
atendia aos padres estabelecidos para a rede BSRN (Baseline Solar climatology of Florianpolis exhibits days with clear sky and overcast
Radiation Network) para coleta e qualificao dos dados coletados. A well distributed all over the year.
climatologia de Florianpolis apresenta dias de cu claro e encoberto
bem distribudos ao longo do ano. A t the three stations Kipp&Zonen CM21 pyranometers and NIP
VALIDATION OF DNI
28 . Histogramas
de freqncia dos desvios
. Histograms of
deviation frequencies
T he validation of the direct
normal irradiation estimates used
entre valores estimados e between estimated and
medidos do total dirio de measured values for daily ground data collected at the
irradiao solar global: (a) global solar irradiation: (a) in SONDA network sites located in
regio Norte, (b) regio the North, (b) in the Petrolina (PE), Florianpolis (SC)
Nordeste, (c) regio Northeast, (c) in the and So Martinho da Serra (RS).
Centro-Oeste, (d) regio Midwest, (d) in the The AWS's and the other SONDA
Sudeste e (e) regio Sul. A Southeast and (e) in the sites do not have a pirheliometer to
linha contnua representa South Brazilian regions. The acquire the direct solar irradiation
a probabilidade continuous line represents
data. The SONDA site in Brasilia is
cumulativa para os the cumulative probability
equipped with a pirheliometer but
desvios observados. for the observed deviations.
the equipment exhibited technical
problems and its data was
VALIDAO discarded.
DA DNI
hemisfrio norte.
33
Atlas Brasileiro de Energia Solar
34
Atlas Brasileiro de Energia Solar
35
Atlas Brasileiro de Energia Solar
36
Atlas Brasileiro de Energia Solar
37
Atlas Brasileiro de Energia Solar
38
Atlas Brasileiro de Energia Solar
39
Atlas Brasileiro de Energia Solar
40
Atlas Brasileiro de Energia Solar
41
Atlas Brasileiro de Energia Solar
ESTUDO DE VARIABILIDADE E VARIABILITY AND TRENDS STUDY
TENDNCIAS
T his topic is for the purpose of evaluating how the solar radiation flux
E ste tpico tem por finalidade avaliar como o fluxo de radiao solar
incidente na superfcie varia em torno dos valores mdios anuais e
varies around the annual and seasonal means exhibited on the previous
maps. Two studies were done and they are presented here: the
sazonais apresentados nos mapas anteriores. Dois estudos foram variability of global solar irradiation along the year and the variability of
realizados e esto apresentados neste documento: um estudo da global solar irradiation in each season (winter, summer, spring and fall).
variabilidade mdia anual e um estudo da variabilidade mdia para
cada estao do ano.
A variabilidade anual, Vanual, aqui utilizada foi definida como a T he annual variability, Vanual, used herein was defined as the average
mdia da variabilidade inter-anual observada para cada dia do ano. A
variabilidade inter-anual, Vd,a, para cada dia do ano foi determinada
of the inter-annual variability observed for each day of the year. The
inter-annual variability, Vd,a, for each day of the year was determined
43
por meio da razo entre o desvio quadrtico mdio e o valor mdio do through the ratio between the mean quadratic deviation and the mean
total dirio do fluxo solar para cada dia do ano no perodo de 1995 a daily solar flux for each day of the year in the time period from 1995 to
2005, descrito pela expresso abaixo: 2005 as presented below:
365 365
DQMd DQMd
2005 2005
o desvio quadrtico mdio para o dia d do ano, Nd o nmero de is the mean quadratic deviation for day d of year, Nd is the number
dias com dados vlidos, Na o numero de anos com dados vlidos, of days with valid data, Na is the number of years with valid data,
Id,a representa o total dirio de irradiao solar global para o dia d no Id,a represents the daily global solar irradiation for day d in year a
ano a e Id o valor mdio de Id,a no perodo de julho de 1995 a and Id is the mean value for Id,a in the period of July 1995 to
dezembro de 2005. December 2005.
significa que o total dirio de irradiao solar global apresentou uma for a spreading of daily values of global solar irradiation up to 45%
disperso mdia de 45% em torno do valor mdio apresentado na around its mean value presented in page 34.
pgina 34.
44
A variabilidade sazonal, Vsazonal, foi definida como a mdia da
T he seasonal variability, Vsazonal, was defined as the mean intra-
seasonal variability observed for each year for the period from 1995 to
variabilidade intra-sazonal observada para cada ano do perodo de 2005. The intra-seasonal variability for specific year, Vsaza, was
1995 a 2005. A variabilidade intra-sazonal para um ano especfico, determined through the ratio between the mean quadratic deviation
Vsaza, foi determinada por meio da razo entre o desvio quadrtico and the mean value of the daily solar flux for the specific season:
mdio e o valor mdio do total dirio do fluxo solar na estao do ano
em estudo, descrito pela expresso abaixo: 2005
Vsaza
2005
a = 1995
Vsaza Vsazonal =
Na
a = 1995
Vsazonal =
Na n2
n2
(Id,a Isaz)2
d = n1
(Id,a Isaz)2 Nd
d = n1
where Vsaza =
Nd Isaz
onde Vsaza =
Isaz
Nd is the number of days with valid data, Na is the number of years
with valid data, Id,a represents the daily global solar irradiation for day
Nd o nmero de dias com dados vlidos, Na o numero de anos
d in year a and Isaz is the average value for global solar irradiation in
com dados vlidos, Id,a representa o total dirio de irradiao solar
global para o dia d no ano a e Isaz o valor mdio da irradiao solar the season. For instance, a seasonal variability equal to 0.45
global na estao do ano. Dessa forma, uma variabilidade sazonal (Vsazonal=0,45) stands for a spreading of daily values of global solar
45
Atlas Brasileiro de Energia Solar
46
Atlas Brasileiro de Energia Solar
47
Atlas Brasileiro de Energia Solar
. Variabilidade dos valores mdios sazonais da . Variability of the seasonal mean values of solar
irradiao solar para as cinco regies geogrficas do Brasil. irradiation for each of the geographical regions of Brazil.
Atlas Brasileiro de Energia Solar
50
E stima-se que o aquecimento de gua responsvel por 25% do total I t is being estimated that water heating is responsible for 25% of the
51
de energia eltrica consumida nas residncias brasileiras o que total electric power consumed in the Brazilian households (electricity
representa um consumo da ordem de 20 bilhes de kWh. Tal demanda consumption around 20 billion kWh). Such demand for electric energy
de energia eltrica ocorre principalmente no fim da tarde ocasionando occurs primarily in the late afternoon causing a demand peak that could
um pico que poderia ser reduzido em grande parte com a explorao be greatly reduced with the exploration of solar energy with economic
da energia solar, trazendo ainda vantagens econmicas e ambientais. O and environmental advantages. The electric showerhead is the
chuveiro eltrico o equipamento mais empregado para esta tarefa, equipment mostly used for water heating as it has a very low cost for
apresenta um custo reduzido para instalao (abaixo de US$15) e pode installation (below US$15) but may consume up to 6kWh
consumir uma potncia de at 6kWh.
. .
(a) Energia total (a) Total
necessria para required energy
aquecimento e for water
(b) tempo de heating and
retorno do (b) payback
investimento time (PB).
(PB).
de 10%aa. O consumo de energia foi estimado assumindo a required energy for heat and (b) the time for a return on the investment
temperatura da gua em 40 C no chuveiro e a temperatura ambiente (PB). The payback is smaller for regions with greater energy demand
Renda inferior a
1.004.826,7 322.303 323,9 2.993,1 2,9
1000US$/ms
combustvel, conquanto que eles operem abaixo do limite de consumo has recently been extended for another 20 years. Utilities are allowed
especfico de 0,34 l/kWh. O perodo de durao desse subsdio to include a surcharge to all urban and rural consumers of the national
governamental foi aumentado para mais 20 anos. As prestadoras de interconnected system to collect funds to subsidize consumers of these
servio so autorizadas a cobrar uma taxa maior de todos os isolated systems. This surcharge system, and the funds collected, are
consumidores urbanos e residenciais do directed to the so-called Isol-CCC Account (Fuel Consumption Account
sistema eltrico interligado brasileiro, de of the Isolated Systems) which sub-sidizes diesel for the thermal plants
maneira a adquirir fundos para subsidiar os in isolated mini-grids.
consumidores desses locais isolados. Esse
sistema de sobre-taxa, e os fundos
arrecadados, so dirigidos dire-
T he potential for using PV, however, is huge, and can be
estimated in tens to hundreds of MWp in the Amazon
tamente a chamada Conta de region alone, even if only a fraction of the 286
Consumo de Combustveis dos existing diesel power plants with a
Sistemas Isolados, que subsidia total installed capacity of over
o diesel das centrais trmicas 620 MVA would adopt
das pequenas redes some PV to an optimum
isoladas. DIESEL-PV mix [37].
O potencial de uso de
PV, no entanto, imenso,
Furthermore, while the
solar radiation resource
distribution in the region
e pode ser estimado de is considerable, and
dezenas a centenas de MWp with a small seasonal
somente na regio amaznica, variation, as de-
mesmo se somente uma monstrated by
parcela das 286 centrais de the resource
54 gerao diesel existentes, com
capacidade de 620MWA,
maps presented
earlier in this
adotassem mdulos PV numa Atlas, the wind
proporo diesel-PV otimizada [37]. resource distribu-
Alm disso, enquanto a tion in the Amazon
distribuio da radiao solar na region is one of the worst in the
regio considervel, e com country (26,45 TWh/ano) [5]. As a result,
pequena variao sazonal, tal Solar PV is one of the most viable renewable
como demonstrado pelo energy technologies currently available for the
mapeamento apresentado neste dispersed and relatively small energy density
Atlas, a distribuio dos recursos demands in the region. Lower diesel consumption during
elicos na regio uma das piores daytime hours and reduction of greenhouse gases
do pas (26,45 TWh/ano) [5]. emission are examples of other
Dessa forma, a tecnologia solar . . benefits bring out by using simple
PV uma das alternativas mais Sistema interligado de distribuio Interconected system for electricity hybrid DIESEL-PV system without
viveis de energia renovvel de eletricidade no Brasil [2]. distribution in Brazil [2]. storage, where PV systems are
atualmente disponvel para atender added to existing diesel thermal
a demanda da regio, que dispersa e de relativamente pequena plants with prospects of future conversion to fuel cell / PV hybrid
densidade energtica. A economia de combustvel fssil e a reduo configurations, in which case energy generation would rely 100% on PV.
de emisso de gases do efeito estufa so exemplos dos benefcios
trazidos pela adoo de um sistema simples com a adio de gerador
fotovoltaico sem capacidade de armazenamento de energia uma
T he solar radiation resource distribution in the region is considerable
(around 5.5 MW/m2), and with a small seasonal variation. These
planta trmica alimentada com leo diesel. Acrescenta-se a isso a features match up the technical standards requirements for mini-hybrid
perspectiva de converso futura para uma configurao systems technology. Figure 21 shows, on an annual average, the daily
fotovoltaico/clula de combustvel resultaria numa gerao 100% PV generation yields, in kWh/kWp, that can be expected for the
limpa e renovvel baseada exclusivamente no recurso solar. amorphous silicon thin-film PV technology deployed at latitude-tilted
arrays in the Amazon region, together with the location of villages/towns
and diesel-fired generation units in the region. Besides all the solar
O mapeamento dos recursos de energia solar mostram um
resource maps shown in this Atlas, the SWERA project provides solar
55
solar, e o alto valor que pode ser dado a sistemas PV em reas
comerciais de centros urbanos [39]. Os mapas de irradiao solar em data on a monthly basis, where seasonal trends can be seen in more
um plano inclinado no valor da latitude local apresentados neste detail (http://swera.unep.net/).
Atlas (pginas 38 e 39) demonstram tanto a possibilidade de
utilizao de PV por todo o pas quanto pequena variao sazonal
ao longo do ano. No levantamento da viabilidade econmica de
projetos PV, informaes mais detalhadas do comportamento GRID-CONNECTED PV SYSTEMS IN URBAN
sazonal da distribuio de radiao solar so necessrias, e a base de AREAS
dados do projeto SWERA disponibiliza o mapeamento desse recurso
solar em resoluo temporal mensal (http://swera.unep.net/).
The impressive growth in the PV market is related to grid-connected
S istemas PV podem contribuir para a capacidade mxima de uma
rede se o pico de demanda ocorre no perodo diurno. Regies
installations
application
in developed countries. There is a huge potential for this
in sunny urban areas all over the world as well. Brazil is
comerciais com altas cargas de ar-condicionado no horrio do particularly well suited for the application of grid-connected PV due to
meio-dia em geral possuem curvas de demanda em boa sincronia both a considerable solar resource availability, and to the high value that
com a radiao solar [40, 41]. Outro fator importante para essa anlise can be attributed to PV in commercial areas of urban centers [39]. The
a comparao entre os valores de pico de carga no inverno e no maps on pages 38 and 39 present the annual and seasonal averages of
vero. Quanto maior a demanda no vero em comparao com o the daily solar radiation availability at the latitude-tilted plane for the
perodo de inverno, maior a possibilidade de a carga coincidir com Brazilian territory, demonstrating both the potential of deploying PV all
a disponibilidade do recurso solar. Esse o comportamento tpico over the country, and the small seasonal variability throughout the year.
na maioria das capitais do Brasil. Curvas de dados de consumo das In the assessment of the economic viability of PV projects, more
reas urbanas de todo o pas mostram diferena entre as regies detailed information on the seasonal behavior of the solar radiation
onde prdios comerciais dominam, apresentando picos de demanda resource distribution is necessary. Similar maps on a monthly basis are
no perodo diurno, e regies residenciais, onde os valores de pico available in SWERA database (http://swera.unep.net/).
de demanda ocorrem ao anoitecer. Para fazer melhor proveito da
natureza distribuda da gerao solar de eletricidade, importante
saber a capacidade PV de diferentes regies da cidade quando
instalando uma nova estao PV, de maneira a selecionar o P V can contribute to a utilitys capacity if the demand peak occurs in
Atlas Brasileiro de Energia Solar
consumidor com maior potencial de crdito. Nesse contexto, o the day-time period. Commercial regions with high midday air-
conceito de Potencial Efetivo de Amenizao de Carga de PV foi conditioning loads have normally a demand curve in a good
definido, para quantificar o potencial de crdito de uma instalao synchronism with the solar irradiance [40, 41]. Another important factor in
PV localizada estrategicamente [41, 42]. A Figura 22 mostra, para uma this analysis, is the comparison between the peak load values in summer
curva de demanda tpica em um centro urbano, o efeito de reduo and winter. The greater the demand in summertime in comparison with
de pico ao adicionar um pequeno nmero de mdulos PV (por the demand in wintertime, the more closely the load is likely to match
exemplo, 2m2 de painis fotovoltaicos de filme fino de silcio amorfo the actual solar resource. This is the typical picture of most capital cities
com 15% de eficincia) para auxiliar na reduo dos requisitos de in Brazil. Utility feeders in urban areas all over the country show distinct
carga da rede. Para determinar o potencial benefcio dos sistemas PV regions where commercial and office buildings dominate, and which
como mostrado na Figura 22, necessrio conhecimento da present daytime peak demand curves, and residential regions where the
distribuio da radiao solar numa base horria, e essa informao peak demand values take place in the evening. To add value to the
pode ser acessada para todo o territrio brasileiro atravs da base de distributed nature of solar generated electricity, it is important to know
dados gerada no projeto SWERA. Em um futuro prximo, quando o the PV capacity of the different regions of a city when installing a PV
uso de sistemas PV inter- power plant, in order to select
ligados rede eltrica se the feeder with the greatest
tornar mais difundido, com a capacity credit. In this context,
reduo dos custos e the concept of the Effective
reconhecimento dos bene- Load Carrying Capacity (ELCC)
fcios da gerao PV of PV was defined, to quantify
distribuda, o levantamento the capacity credit of a
do Potencial Efetivo de strategically sited PV ins-
Amenizao de Carga ser de tallation [41, 42]. Figure 22 shows,
alto valor estratgico para for a typical daytime peaking
fornecedores de energia e utility feeder in an urban
56 investidores.
. Efeito de reduo de pico ao . Peak-shaving effect of
center, the peak-shaving effect
of adding a small amount of PV
to assist in reducing the load
adicionar-se um pequeno nmero de adding a small amount of PV to assist in
mdulos PV para auxiliar na reduo reducing the load requirements of the requirements of the feeder (for
dos requisitos de carga da rede numa feeder for a typical daytime peaking example using 2m2 of a thin
curva de demanda tpica de um centro utility feeder in an urban center. amorphous silicon PV pannel
urbano. with efficiency around 15%).
To determine the capacity
benefits of PV as shown in Figure 22, knowledge of the solar radiation
resource distribution on an hourly basis is necessary, and this
information can be retrieved for the whole of the Brazilian territory
through SWERA. In the near future, when the use of grid-connected PV
becomes more widespread due to both cost reductions and the
acknowledgment of the benefits of distributed PV, the assessment of
ELCC will be of strategic value for utilities and investors.
Atlas Brasileiro de Energia Solar
REFERNCIAS BIBLIOGRFICAS (REFERENCES)
1. Goldemberg, J.; Villanueva, L. D. Energia, meio ambiente e desenvolvimento. So Paulo: EDUSP, 225p., 2003.
2. Agncia Nacional de Energia Eltrica, Ministrio de Minas e Energia. Balano Energtico Nacional - BEN 2004, 2004. [online]
http://www.mme.gov.br/, 2005.
3. Stivari, S. M. S; Oliveira, A. P.; Soares, J. On the climate impact of the local circulation in the Itaipu lake rea. Climatic Change, 72(1-2):103-121,
2005.
4. Fearnside, P. M. Do hydroeletric dams mitigate global warming? The case of Brazils Curu-Una dam. Mitigation and Adaptation Strategies for
Global Change, 10:675-691, 2005.
5. Centro de Pesquisas de Energia Eltrica. Atlas do Potencial Elico Brasileiro. CEPEL/ELETROBRS/Ministrio de Minas e Energia. 45p., 2001.
6. Tiba, C. Atlas Solarimtrico do Brasil banco de dados terrestres. Recife: Editora Universitria da UFPE, 2000.
7. Colle, S.; Pereira, E. B. Atlas de irradiao solar do Brasil 1. verso para irradiao global derivada de satlite e validada na superfcie. Braslia:
Instituto Nacional de Meteorologia, 1998.
8. Pereira, E.B., Colle, S. A energia que vem do sol. Cincia Hoje. 22(130): 24-35. 1997.
9. Perez, R.; Seals, R.; Zelenka, A. Comparing Satellite Remote Sensing and Ground Network Measurements for the Production of Site/Time Specific
Irradiance Data. Solar Energy, 60 (2): 89-96, 1997.
10. Guarnieri, R. A.; Martins, F. R.; Silva, S. A. B.; Pereira, E. B. Avaliao de estimativas de radiao solar incidente baseadas em extrapolao e
57
interpolao na regio sudeste do Brasil. Anais do XIV Congresso Brasileiro de Meteorologia realizado em Florianpolis, 2006.
11. Gambi, W. Avaliao de um modelo fsico estimador de irradincia solar baseado em satlites geoestacionrios. Dissertao de Mestrado.
Universidade Federal de Santa Catarina. Florianpolis, 1998.
12. Lenoble, J. Radiative transfer in scattering and absorbing atmospheres: standard computational procedures. Virginia: A. Deepak Publishing,
1985.
13. Martins, F. R. Influncia do processo de determinao da cobertura de nuvens e dos aerossis de queimada no modelo fsico de radiao
BRASIL-SR. Tese de Doutoramento apresentada no Instituto Nacional de Pesquisas Espaciais. So Jos dos Campos, Agosto 2001.
14. Stuhlmann, R.; Rieland, M.; Raschke, E. An improvement of the IGMK model to derive total and diffuse solar radiation at the surface from satellite
data. J. Applied Meteorology, 29(7): 586-603, 1990.
15. Pereira, E. B.; Martins, F. R.; Abreu, S. L.; Couto, P.; Stuhlmann, R.; Colle, S. Effects of burning of biomass on satellite estimations of solar irradiation
in Brazil. Solar Energy, 68(1): 91-107, 2000.
16. Leckner, B. The spectral distribution of solar radiation at the Earths surface elements of a model. Solar Energy, 20(2): 143-150, 1978.
17. McClatchey, R. A.; Fenn, R. W.; Selby, J. E. A.; Volz, F. E.; Garin, J. S. Optical properties of atmosphere. Bedford, Massachusetts: Air Force
Cambridge Research Laboratories, (AFCRL-72-0497), 108p, 1972.
18. Warren, S. G.; Hahn, C. J.; London, J.; Chervin, R. M.; JennE, R. Global distribution of total cloud cover and cloud types amount over land.
DOE/ER/60085-H1, NCAR/TN-273+STR, NCAR Technical Notes, 1986.
19. Stephens, G. L. Radiation profiles in extended water clouds. II: parameterization schemes. Journal of Atmospheric Science, 35: 2123-2132, 1978.
20. Sellers, P.J.; Los, S.O.; Tucker, C.J.; Justice, C.O.; Dazlich, D.A.; Collatz, G.J.; Randall, D.A.. A revised land surface parameterization (SiB2) for
atmospheric GCMs. Part 2: The generation of global fields of terrestrial biophysical parameters from satellite data. Journal of Climate, 9:706-737,
1995.
21. Harshvardhan; Davies, R.; Randall, D.A.; Corsetti, T.G. A fast radiation parameterization for general circulation models. Journal of Geophysical
Research, 92:1009-1016, 1987.
Atlas Brasileiro de Energia Solar
22. BSRN, Baseline Solar Radiation Network Quality Assurance of Database. World Meteorological Organization. [online]: http://bsrn.ethz.ch/.
23. Ceballos, J. C.; Bottino, M. J.; Souza, J. M. A simplified physical model for assessing solar radiation over Brazil using GOES 8 visible imagery. Journal
of Geophysical Research, 109, D2, D02211 10.1029/2003JD003531, 2004.
24. Rigollier, C.; Lefreve, M.; Wal, L. The method HELIOSAT-2 for deriving shortwave solar radiation from satellite images. Solar energy, 77:159-169,
2004.
25. Zelenka , A.; Perez, R.Prediciting solar irradiance from satellite Estimated global irradiance and cloud cover. Application of Satellite Technology -
Annual Progress Report. Geneva: World Meteorological Organization, 1986.
26. Perez, R. Seals, R.; Stewart, R. Modelling irradiance on tilted planes: a simpler version of the Perez Model. Proc. of ISES World Congress in
Hamburg, Germany, 1987.
27. Perez, R. Seals, R.; Ineichen, P.; Stewart, R.; Menicucci, D. A new simplified version of the Perez Diffuse irradiance model for tilted surfaces, Solar
Energy, 39: 221-232, 1987.
28. Diekmann, F. J.; Happ, S.; Rieland, M.; Kln, Benesch, W.; Offenbach, Czeplak, G.; Kasten F. An operational estimate of global solar irradiance at
ground level from METEOSAT data: results from 1985 to 1987. Meteorol. Rdsch., 41, 65-79, 1988.
29. INMET. Normais Climatolgicas 1931 a 1990. [online] http://www.inmet.gov.br/.
30. Beyer, H. G.; Pereira, E. B.; Martins, F. R.; Abreu, S. L.; Colle, S.; Perez, R.; Schillings, C.; Mannstein, H.; Meyer, R.. Assessing satellite derived
irradiance information for South America within the UNEP resource assessment project SWERA. Proceedings of the 5th Ises Europe Solar
Conference, held in Freiburg, Germany, 2004.
31. Martins, F. R.; Pereira, E. B., Abreu, S. L.; Beyer, H. G.; Colle, S.; Perez, R.; Heinemann, D. Cross-validation of the satellite radiation transfer models
during SWERA project in Brazil. Proceedings of the ISES World Congress, held in Goteborg, Sweden, 2003.
32. Perez, R.; Ineichen, P.; Moore, K.; Kmiecik, M.; Chain, C.; George, R.; Vignola, M. A new operational modelfor satellites irradiances: description and
58 validation. Solar Energy, 73(5): 307-317, 2002.
33. European Database for Daylight and Solar Radiation, 2005. [online]:http://www.satel-light.com/.
34. Associao Brasileira de Refrigerao, Ar Condicionado, Ventilao e Aquecimento. [online]: http://www.abrava.com.br/.
35. Duffie J. A.; Beckman, W. A. Solar Engineering of Thermal Processess. New York: John Wiley, 2nd edition, 1991.
36. Rther, R.; Schmid, A.; Beyer, H. G.; Montenegro, A.A.; Oliveira, S.H.F. Cutting on Diesel, boosting PV: The potential of hybrid DIESEL-PV systems
in existing mini-grids in the Brazilian Amazon, Proceedings of the 3rd World Conference on Photovoltaic Energy Renewable and Rural Electrification
Conversion, Osaka - Japan, 555 558, 2003.
37. Beyer, H.G.; Rther, R.; Oliveira, S.H.F. PV systems as option to assist Diesel based electricity supply in the Brazilian Amazon, in, Ed. G.
Chakravarthy, A. Shukla & A. Misra, pp. 179 194, 2004.
38. ONS, Operao Nacional do Sistema Eltrico Interligado: dados relevantes de 2001.
39. Rther, R. Edificios Solares Fotovoltaicos: O potencial da gerao solar fotovoltaica integrada a edificaes urbanas e interligada rede eltrica
pblica no Brasil, ISBN 858758304-2, pp. 1 113, 2004.
40. Perez, R.; Letendre, S.; Herig,C. PV and Grid Reliability: Availability of PV Power during Capacity Shortfalls, Proceedings of the American Solar
Energy Society - ASES Annual Conference, Washington, DC, , 1-4, 2001.
41. Knob, P.; Rther, R.; Jardim, C.S.; Beyer, H.G. Investigating the peak demand reduction capability of PV: A case study in Florianopolis, south
Brazil, Proceedings of the 19th European Photovoltaic Solar Energy Conference, Paris France, 877 890, 2004.
42. Perez, R.; Seals, R.; Herig, C. PV can add capacity fo the grid, NREL Publication DOC/GO-10096-262, NREL, Golden USA, 1996.
Atlas Brasileiro de Energia Solar
NDICE DE FIGURAS FIGURES INDEX
Figura 1. Figure 1.
(a) Matriz energtica brasileira e (b) Matriz de... 9 (a) Brazilian energy matrix and (b) Electric power matrix 9
Figura 2. Figure 2.
Comparao dos desvios rRMSE das estimativas... 13 Comparison between rRMSE deviations observed for... 13
Figura 3. Figure 3.
Diagrama simblico dos processos de interao... 14 Diagram of radiative processes of solar radiation in the... 14
Figura 4. Figure 4.
Fluxograma do modelo de transferncia radiativa BRASIL-SR 14 Flowchart of the BRASIL-SR radiative transfer model 14
Figura 5. Figure 5.
Localizao das estaes da base de dados do... 20 Location of surface stations available in the NCDC database 20
Figura 6. Figure 6.
Mapa da mdia anual de temperatura obtido por... 20 Map for annual mean of temperature obtained... 20
Figura 7. Figure 7.
Mapa da mdia anual de visibilidade obtido por...
Figura 8.
20 Map for annual mean of visibility obtained by...
Figure 8.
20
59
Mapa da mdia anual de albedo de superfcie obtidos por... 20 Map for annual mean of surface albedo obtained... 20
Figura 9. Figure 9.
Mapa da mdia anual de umidade relativa obtido por... 22 Map for annual mean of relative humidity obtained... 22
Figura 10. Figure 10.
Imagem de relevo gerada por interpolao (vizinho mais... 22 Topography image obtained from the nearest neighbor... 22
Figura 11. Figure 11.
(a) Mdulo de medidas da estao SONDA em Braslia... 22 (a) Container of the SONDA site in Brasilia with the... 22
Figura 12. Figure 12.
Comparao entre as estimativas do modelo BRASIL-SR... 26 Scatter graphs between BRASIL-SR estimates for the daily... 26
Figura 13. Figure 13.
Histogramas de freqncia dos desvios entre valores... 28 Histograms of deviation frequencies between estimated... 28
Figura 14. Figure 14.
Grfico de disperso entre valores medidos e estimados... 28 Scatter plot between measured and estimated values... 28
Figura 15. Figure 15.
Potencial anual mdio de energia solar em cada uma... 48 Annual average potential of solar energy for each... 48
Figura 16. Figure 16.
Variabilidade dos valores... ao longo do ano para cada... 48 Variability of the annual mean values of solar irradiation... 48
Figura 17. Figure 17.
Variabilidade dos valores mdios sazonais... para as cinco... 48 Variability of the seasonal mean values of solar irradiation... 48
Figura 18. Figure 18.
Anlise de regresso linear aplicada s mdias anuais... 50 Linear regression analysis applied to the annual mean of... 50
Figura 19. Figure 19.
(a) Energia total necessria para aquecimento e (b) tempo... 52 (a) Total required energy for water heating and (b) payback... 52
Atlas Brasileiro de Energia Solar
Tabela 1. Table 1.
Estaes da rede SONDA utilizadas na etapa... 22 The SONDA sites used to validate solar estimates... 22
Tabela 2. Table 2.
Nmero de PCD utilizadas para validao do... 24 The AWS sites used to validate solar data provided... 24
Tabela 3. Table 3.
Desvios observados para as estimativas fornecidas... 26 Deviations observed for the BRASIL-SR estimates... 26
60 Tabela 4.
Desvios apresentados pelas estimativas de irradiao... 28
Table 4.
Deviations presented by direct normal radiation estimates... 28
Tabela 5. Table 5.
Resultados apresentados para o cenrio de adoo de... 52 Results shown for the solar water heating scenario that... 52
Tabela 6. Table 6.
Estudo de Caso para a cidade de Braslia... 52 A case study for Brasilia - the results obtained for the... 52