Escolar Documentos
Profissional Documentos
Cultura Documentos
ComandosTellabs Usados PDF
ComandosTellabs Usados PDF
Adm. Redes TX
Tipos de interfaces
ge = Gigabit Ethernet
fe = Fast Ethernet
pdh = PDH
mp = MLPPP
so = SDH
Interface ge1/0
L1 Admin Status: up, L1 Fault Status: ok
Loop: not set, Loop Timeout: 15 min
Connector: RJ45S
MAU Media Availability: available
Auto Neg: enabled, Auto Neg Status: complete
Default MAU: 100BASE-TX FDX
Remote Auto Neg Signalling: detected
Remote Auto Neg Capability: 10BASE-T HDX, 10BASE-T FDX, 100BASE-TX HDX, 100BASE-
TX FDX
Auto Neg Fault Status:
Local: no error, Remote: no error
Operational MAU: 100BASE-TX FDX
SSM Transmission: enabled
Egress bandwidth rate limit: max
Counters:
Drops: 0, False Carrier: 0
Alignment Errors: 0, FCS Check Failed: 0
Single Collisions: 0, Multiple Collisions: 0
Late Collisions: 0, Excessive Collisions: 0
In Pause Frames: 0, Out Pause Frames: 0
Unknown Opcodes: 0, Carrier Sense Lost: 0
Giants: 0
Deferred Transmissions (busy): 0
L1 ge1/0
Port protocol: Ethernet, MTU: 1530
Logical ge1/0
MAC Address: 00b0.c7dc.fd1a (in use), Configured MAC Address: 0000.0000.0000
Bandwidth: 100M, Allocated bandwidth: 200M
IF Module BW alloc.: required 1600, allocated 1600, free 2000
Encapsulation: ethernetIIWithType(ARPA)
Counters:
RX Octets: 195609157, RX Unicast: 1447861
RX Multicast: 1066, RX Broadcast: 0
RX Discarded: 0, RX Errors: 0
RX Unknown Protocol: 0, RX Drop RL: 0
TX Octets: 94546718, TX Unicasts: 1092777
TX Multicast: 1066, TX Broadcast: 2
TX Discarded: 0, TX Errors: 0
TX Drop RL: 0
Existing Vlans:
L2 ge1/0
Link up
Para verificar datos generales de layer 1 y 2 en una interface
MLPPP
X0264A8620_Quilloamira#show interface mp0
ML-PPP 0
Sequence number Type:
Conf: long, receiving: long, sending: long
Sequence Numbers: Sending next: 0x00034233 Last received: 0x0001b8aa
Timeout 32 ms
Fragmentation: dynamic, Max fragment Size: - bytes
Header Settings: ML headers always in use
MRRU size:
Configured: 1700 bytes, Negotiated: 1500 bytes
PFC enabled
Active Links: 6, min-links: 1, Max Diff Delay: 25000 us
Bandwidth: 11 904 kbps
Event Dampening:
Integration time 10 s, Outage threshold 3
Restoration time 10 s
Differential Delay Monitoring: disabled
Counters:
RX Octets: 7008037 Packets: 110414
Sequence underruns: 0
Errors: 0
Unknown Protocol: 0
MRRU Exceeds: 0
Buffer Overruns: 0
Unavailable Buffer Pool: 0
TX Octets: 15057189 Packets: 206953
Configured PPP Links (6):
pdh0/0:0 State: opened Frag size 252 : TX 35590 RX 10057
pdh0/1:0 State: opened Frag size 252 : TX 35591 RX 23410
pdh0/2:0 State: opened Frag size 252 : TX 35592 RX 4721
pdh0/3:0 State: opened Frag size 252 : TX 35597 RX 70188
pdh0/4:0 State: opened Frag size 252 : TX 35594 RX 2796
pdh0/5:0 State: opened Frag size 252 : TX 35591 RX 1640
PPP IP CP mp0
State: opened
Protocol Errors: 0
PPP MPLS CP mp0
State: stopped
Protocol Errors: 0
PPP OSINL CP mp0
State: stopped
Para verificar datos generales de layer 3 en una interface
Ethernet
Interface ge1/0
Hardware is Ethernet, address is 00:b0:c7:dc:fd:1a
Description: Trunk a X0211
index 5004 metric 1 mtu 1400 <UP,BROADCAST,RUNNING,SIMPLEX,MULTICAST>
Link mtu 1530 ip mtu 1400 mpls mtu 1530
VRF Binding: Not bound
Proxy arp is disabled
ICMP unreachables are sent
Directed broadcasts are not forwarded
Label switching is enabled
No Virtual Circuit configured
Administrative Group(s): None
Bandwidth 100M
DSTE Bandwidth Constraint Mode is RSDL
inet 10.84.5.17/30 broadcast 10.84.5.19
input octets 60151, unicasts 546, receives 546,
errors 0
output octets 76339, unicasts 613
starting conf-snap
taking conf-snap from unit 1.
all files were zipped successfully from unit 1
conf-snap succeeded