Escolar Documentos
Profissional Documentos
Cultura Documentos
2
0
eu
Rate This
(https://dmohankumar.files.wordpress.com/2015/09/battery-charge-
indicator-2.jpg)Este é um circuito simples, mas muito útil para você.
A maioria de nós usa diferentes tipos de baterias recarregáveis em
dispositivos portáteis, inversores, lâmpadas de emergência, etc. Se a
bateria estiver profundamente descarregada, às vezes ela não será
totalmente carregada mais tarde. Este é o motivo mais comum para a
falha da lâmpada de emergência. Portanto, precisamos de um
indicador para mostrar o nível seguro de tensão da bateria. É muito
simples de fazer e precisa de apenas três componentes. Basta conectá-lo na bateria e ele irá lembrá-lo
quando precisar de carga.
Cada tipo de bateria recarregável tem um limite de tensão seguro. A bateria de chumbo-ácido de 12 V
atinge carga total em 13,8 volts e a bateria tubular em 14,8 V. A bateria de 9 V mostra a carga
completa como 9,6 V and 6 V battery as 6.8V. So how much it can discharge. Some battery can
discharge to 50% but is ideal to keep 80% charge in it. That means, charging requires when 20%
discharge occurs. But the condition of NimH and Li-Ion batteries used in Mobile phone, Digital
Camera etc is different. These batteries attain full charge even if they are discharged completely.
É um simples indicador controlado por tensão . UMAZener diode (ZD) is used as a voltage
controlled switch. In the circuit, the Cathode of Zener is connected to the Positive terminal of battery.
To its Anode, a Red LED with a 100 Ohms series resistor is connected. The other end of resistor is
connected to the Negative terminal of the battery.
https://dmohankumar.wordpress.com/2015/09/15/battery-charge-indicator-simple-design-5/ 1/5
26/03/22, 14:57 Indicador de carga da bateria. Simple Design 5 – blog de eletrônica de Mohan
(https://dmohankumar.files.wordpress.com/2015/09/battery-charging-reminder.jpg)
Now let us see what happens to this circuit. As you know, the Zener conducts only when it gets a
higher voltage than its value. For example, a 5 Volt zener conducts when it gets 6 volts and below 5
volts, it remains off. So here a Red LED is selected as the indicator. It has a forward voltage drop of
1.7 volts. This makes the trick to fix the “charging reminding point”. That means
Valor Zener + 1,7 V é o ponto de lembrança . Quando a tensão na bateria estiver acima deste valor, o
Zener conduz e o LED permanece aceso. Quando a tensão da bateria diminui abaixo disso, o LED
desliga para indicar a necessidade de carregamento. Por exemplo, tome o exemplo de uma bateria de
chumbo-ácido de 12 volts. Atinge carga total em 13,8 volts. Então pegue um Zener de 10 V.
Então, até que a bateria retenha a tensão acima de 11,7 volts ,LED remains on. When it turns off, it
indicates that, the voltage reduced below 11.7 volts and needs charging.
https://dmohankumar.wordpress.com/2015/09/15/battery-charge-indicator-simple-design-5/ 2/5
26/03/22, 14:57 Indicador de carga da bateria. Simple Design 5 – blog de eletrônica de Mohan
(https://dmohankumar.files.wordpress.com/2015/09/battery-charging-indicator.jpg)
(https://dmohankumar.files.wordpress.com/2015/09/battery-charge-indicator-21.jpg)
You can select the Zener value in another way. Minus 1.7 V from the full charge voltage. It will give
the Zener value. But this has one problem. The battery voltage may vary from 12 V to 13.8 V. If we
take the Zener value like this, it may change the charge remind point. So fixing the “reminding point”
is best as per the method explained. Note that, 1.7 V is for Red LED only. If you use Green LED, it
will be 2 volts.
Esta técnica simples é usada em Inversores para carregamento automático e, como corte automático .
Quando a tensão da bateria diminui abaixo de 11,5 ou 11 V, um relé é ligado para carregar a bateria.
A única desvantagem do circuito é que o LED consome alguma corrente mesmo quando a carga está
desligada. Sem problemas. A bateria precisa carregar e descarregar para manter sua saúde.
Então tente isso. O valor de Zener para diferentes baterias é dado abaixo.
(https://dmohankumar.files.wordpress.com/2015/09/low-battery-indicator-zene.jpg)
Anúncios
https://dmohankumar.wordpress.com/2015/09/15/battery-charge-indicator-simple-design-5/ 3/5
26/03/22, 14:57 Indicador de carga da bateria. Simple Design 5 – blog de eletrônica de Mohan
https://dmohankumar.wordpress.com/2015/09/15/battery-charge-indicator-simple-design-5/ 4/5
26/03/22, 14:57 Indicador de carga da bateria. Simple Design 5 – blog de eletrônica de Mohan
https://dmohankumar.wordpress.com/2015/09/15/battery-charge-indicator-simple-design-5/ 5/5