Escolar Documentos
Profissional Documentos
Cultura Documentos
Especialidad:
Sección:
3-C1-A
Profesor:
Integrantes:
ÍNDICE:
1. Objetivos 3
2. Resumen 3
3. Abstract 4
4. Procedimientos 6
4.1 Experiencia 1 6
4.2 Experiencia 2 7
4.3 Experiencia 3 8
5. Cálculos y Discusión de resultados 9
5.1. Experiencia 1: 9
5.2. Experiencia 2: 11
5.3. Experiencia 3: 12
6. Conclusiones 14
8. Bibliografía 15
9. ATS 16
1. Objetivos
OBJETIVOS GENERAL:
OBJETIVO ESPECÍFICO:
2. Resumen
para ello se utilizó un vaso de Tecnopor como sistema, al cual se le añadió una
cantidad de agua destilada hasta que pesar 45 gr, se tapó el calorímetro, fue llevado a
como catalizador el Fe(NO3)3, por tanto, mediante el uso de una probeta de 100 mL
vertió 100 mL en un vaso de 150 mL, esta cantidad paso por previo control de
temperatura entre (10-25 °C), colocándolo en un vaso de 600 mL con agua y algunos
procedió lo siguiente de igual forma que en la etapa anterior, aunque se usó para esta
respectivo análisis.
3. Abstract
enthalpy of destruction was applied. The first experience refrained from this concept,
because it was required to find the heat capacity of the calorimeter, for this a glass of
Tecnopor was obtained as a system, to which a quantity of distilled water was added
until it weighed 45 gr, it was covered the calorimeter was taken to the heating plate in
water was added and placed on the plate in heat mode, bringing it to a temperature of
8°C above the temperature of the water in the calorimeter; This was then carefully
poured into the calorimeter and the same process as in the distilled water was
and its temperature was measured for 5 minutes, then 10 mL of 0.5M Fe(NO3)3 was
pipetted, it was added to the calorimeter with caution after 5 minutes, it was closed
immediately and its temperature of the mixture was measured about 20 minutes. The
third experience was similar to the previous one, with the difference in the H2O2
concentration (0.5%) and the use of another catalyst (MnO2). In the measurement of
0.5% H2O2, 100 mL was poured into a 150 mL glass, this quantity passed through
prior temperature control between (10-25°C), placing it in a 600 mL glass with water
and some ice cubes. , then, from the glass with 100 mL, 50 mL was pipetted into the
calorimeter and the following procedure was carried out in the same way as in the
previous stage, although 25 ± 1 mg of MnO2 was used for this experiment, previously
carefully weighed, on the analytical balance . At the end, all the data obtained were
4.1 Experiencia 1
4.2 Experiencia 2
4.3 Experiencia 3
5. Cálculos y Discusión de resultados
Cálculos:
Antes del desarrollo de ecuaciones de ecuaciones, hallamos el valor de la masa del agua
m=ρ∗V
m=
Ahora encontramos la capacidad calorífica:
−Q pierde =Qgana
−W a ×C a ( ΔT )=C p ( ΔT )+W a ×C a ( ΔT )
C p=50.636 J /ºC
5.2. Experiencia 2:
Observación:
En este segundo experimento se determinó la entalpía de neutralización entre un ácido
y una base fuerte, en donde la primera medida fue el volumen de NaOH y la toma de
temperatura, para así poder agregar HCl y realizar la respectiva reacción; obteniendo
como productos NaCl, una sal y agua. En esta reacción, se evidenció la unión de los
iones hidratados de hidrógeno e hidroxilo para formar agua no ionizada debido a que
respectivamente) dado que se encuentran en una solución acuosa diluida, este proceso
sistema.
Temperatura vs tiempo
del H2O2
t (min) T (°C)
1 21.7
2 21.6
3 21.6
4 21.6
5 21.6
Temperatura vs tiempo
H2O2 + Fe(NO3)3
t (m) T (°C)
1 28.8
2 34.0
3 35.7
4 35.9
5 35.7
6 35.5
7 35.2
8 35.1
9 34.8
10 34.5
11 34.2
12 34.0
13 33.7
14 33.4
15 33.2
6. Conclusiones
7. Cuestionario
8. Bibliografías
http://corinto.pucp.edu.pe/quimicageneral/contenido/143-calculo-del-calor-de-
reaccion-ley-de-hess.html
https://www.quimica.es/enciclopedia/Ley_de_Hess.html
https://www.quimitube.com/videos/termodinamica-teoria-14-calculo-de-la-
entalpia-de-una-reaccion-por-la-ley-de-hess/
https://conceptodefinicion.de/ley-de-hess/
9. ATS