Escolar Documentos
Profissional Documentos
Cultura Documentos
1. (10 min) Uma esfera de m = 100 g é lançada da posição x = 0 com velocidade 0,100 m/s e
escorrega sem atrito ao longo de uma calha cuja forma é dada pela expressão
e cujo gráfico é ilustrado na figura. Os valores na expressão anterior estão expressos em SI.
Determine:
a. a velocidade máxima da partı́cula.
b. se a esfera atinge o ponto x = 2.
2. (20 min) Exerce-se uma força sobre o bloco maior que assim se desloca com aceleração
constante a. Determine o valor de a para o qual nenhum dos blocos mais pequenos desliza.
m m
O atrito entre todas as superfı́cies é irrelevante.
Figure 4.22 Figure 4.23
m1
4.14. No relative motion
M All of the surfaces in the setup in Fig. 4.25 are frictionless. Y
m2 and give it an acceleration a. For what value of a is there no
a masses?
4.15. Slipping blocks
A block with mass m sits on top of a block with mass 2m
(side view) coefficients of friction (both static and kinetic) between all su
string is connected to each mass and wraps halfway around a p
Figure 4.25 You pull on the pulley with a force of 6mg.
Se não houver movimento relativo entre os blocos, então m2 não se move-se verticalmente.
Da segunda lei de Newton aplicada ao bloco de massa m2 resulta que (a) Explain whyno
a tensão thefio
bottom
a eleblock must slip with respect to t
it doesn’t slip, and show that this leads to a contradiction
ligado vale m2 g (em módulo). A tensão no fio que liga m1 a m2 é portanto m2 g (em módulo).
(b) Explain na
Aplicando a segunda lei de Newton aplicada ao bloco de massa m1 obtém-se, whydireção
the top block
Ox: must slip with respect to the b
(c) What is the acceleration of your hand?
T = m1 a → m2 g = m1 a → a = g
µ=1 F = 6m
m
Uma vez que não há movimento relativo, a aceleração do bloco maior de massa M é também
2m
g.
Figure 4.26
Nota: deve resolver o problema, criando diagramas de corpo livre para cada um dos sistemas
(3 blocos + roldana), escrever as equações da dinâmica de cada4.16. Block
um dos and wedge
corpos e as equações de
ligação e depois resolver as equações da dinâmica. Apresentamos aqui
A block with uma
apenas mass Mresolução
rests on a wedge with mass m and ang
M
abreviada. as shown in Fig. 4.27. All surfaces are frictionless. The bl
vertically by means of a wall on its left side. What is the accel
m
θ 4.17. Up and down a plane
A block with mass m is projected up along the surface of a pla
Figure 4.27 initial speed is v0 , and the coefficients of both static and kinetic
block reaches a highest point and then slides back down to the
(a) Show that in order for the block to in fact slide back do
rest at the highest point), θ must be greater than 45◦ .
(b) Assuming that θ > 45◦ , find the times of the up and dow
(c) Assuming that θ > 45◦ , is the total up and down time lon
time it would take (with the same initial v ) if the plane